Trane Ascend ACR Series, Инструкция по установке, эксплуатации и обслуживанию

Страница: 23 / 112

AC-SVX001A-EN 23
Installation Mechanical
Location Requirements
Sound Considerations
• Locate the unit away from sound-sensitive areas.
• Install the optional elastomeric isolators under the
unit. See Isolation and Sound Emission section.
• Chilled water piping should not be supported by
chiller frame.
• Install rubber vibration isolators in all water piping.
• Use flexible electrical conduit.
• Seal all wall penetrations.
N No otte e:: Consult an acoustical engineer for critical
applications.
Foundation
Provide rigid, non-warping mounting pads or a
concrete foundation of sufficient strength and mass to
support the applicable operating weight (i.e., including
completed piping, and full operating charges of
refrigerant, oil and water). See Dimensions and
Weights chapter for unit operating weights. Once in
place, the unit must be level within 1/4” (6.4 mm)
across the length and width of the unit. The Trane
Company is not responsible for equipment problems
resulting from an improperly designed or constructed
foundation.
Clearances
Provide enough space around the unit to allow the
installation and maintenance personnel unrestricted
access to all service points. See submittal drawings for
the unit dimensions, to provide sufficient clearance for
the opening of control panel doors and unit service.
See Dimensions and Weights chapter for minimum
clearances. In all cases, local codes which require
additional clearances will take precedence over these
recommendations.
For close spacing information, see RLC-PRB037*-EN.
Lifting and Moving Instructions
W WA AR RN NIIN NG G
H He ea av vy y O Ob bjje ecctt!!
F Fa aiillu urre e tto o ffo ollllo ow w iin nssttrru uccttiio on nss b be ello ow w cco ou ulld d rre essu ulltt iin n
u un niitt d drro op pp piin ng g w wh hiicch h cco ou ulld d rre essu ulltt iin n d de ea atth h o orr
sse erriio ou uss iin njju urry y,, a an nd d e eq qu uiip pm me en ntt o orr p prro op pe errtty y--o on nlly y
d da am ma ag ge e..
E En nssu urre e tth ha att a allll tth he e lliiffttiin ng g e eq qu uiip pm me en ntt u usse ed d iiss
p prro op pe errlly y rra atte ed d ffo orr tth he e w we eiig gh htt o off tth he e u un niitt b be eiin ng g
lliifftte ed d.. E Ea acch h o off tth he e cca ab blle ess ((cch ha aiin nss o orr sslliin ng gss)),, h ho oo okkss,,
a an nd d ssh ha acckklle ess u usse ed d tto o lliifftt tth he e u un niitt m mu usstt b be e cca ap pa ab blle e
o off ssu up pp po orrttiin ng g tth he e e en nttiirre e w we eiig gh htt o off tth he e u un niitt.. L Liiffttiin ng g
cca ab blle ess ((cch ha aiin nss o orr sslliin ng gss)) m ma ay y n no ott b be e o off tth he e ssa am me e
lle en ng gtth h.. A Ad djju usstt a ass n ne ecce essssa arry y ffo orr e ev ve en n u un niitt lliifftt..
W WA AR RN NIIN NG G
IIm mp prro op pe err U Un niitt L Liifftt!!
F Fa aiillu urre e tto o p prro op pe errlly y lliifftt u un niitt iin n a a L LE EV VE EL L p po ossiittiio on n
cco ou ulld d rre essu ulltt iin n u un niitt d drro op pp piin ng g a an nd d p po ossssiib blly y
ccrru ussh hiin ng g o op pe erra atto orr//tte ecch hn niicciia an n w wh hiicch h cco ou ulld d rre essu ulltt iin n
d de ea atth h o orr sse erriio ou uss iin njju urry y,, a an nd d e eq qu uiip pm me en ntt o orr
p prro op pe errtty y--o on nlly y d da am ma ag ge e..
T Te esstt lliifftt u un niitt a ap pp prro ox xiim ma atte elly y 2 24 4 iin ncch he ess ((6 61 1 ccm m)) tto o
v ve erriiffy y p prro op pe err cce en ntte err o off g grra av viitty y lliifftt p po oiin ntt.. T To o a av vo oiid d
d drro op pp piin ng g o off u un niitt,, rre ep po ossiittiio on n lliiffttiin ng g p po oiin ntt iiff u un niitt iiss
n no ott lle ev ve ell..
W WA AR RN NIIN NG G
P Prro op pe err L Liiffttiin ng g C Co on nffiig gu urra attiio on n
R Re eq qu uiirre ed d!!
F Fa aiillu urre e tto o ffo ollllo ow w iin nssttrru uccttiio on nss b be ello ow w cco ou ulld d cca au usse e
tth he e u un niitt tto o d drro op p w wh hiicch h cco ou ulld d rre essu ulltt iin n d de ea atth h,,
sse erriio ou uss iin njju urry y o orr e eq qu uiip pm me en ntt d da am ma ag ge e..
U Usse e O ON NL LY Y lliiffttiin ng g llo occa attiio on nss d de essiig gn na atte ed d w wiitth h lla ab be ell
ssh ho ow wn n b be ello ow w.. D DO O N NO OT T u usse e llo occa attiio on nss m ma arrkke ed d w wiitth h
d do o--n no ott--lliifftt lla ab be ell.. S Se ee e ffo ollllo ow wiin ng g ffiig gu urre ess ffo orr
a acccce ep ptta ab blle e lliiffttiin ng g cco on nffiig gu urra attiio on n,, a an nd d rre effe err tto o lla ab be ellss
o on n tth he e u un niitt..
Figure 6. Lift/Do Not Lift labels
Lift Do Not Lift