7.
6.
Convection Toaster Oven-Broiler Dehydration Racks Use and Care Guide
Preparation and Pretreatment
of Fruits
Almost all fruits are suitable for drying at home, but some fruits will
require more drying time than others; the guidelines offered in this
manual will help you get started. Some fruits might not be suitable
for drying all year round, so it will be helpful to learn which fruits are
in season and experiment with those first.
Preparation
Wash fruits well and remove any bruised or overripe portions. Peel if
desired. Larger fruits may be halved. If pieces of fruit vary in size,
they may be sliced
3
⁄
8
" to
1
⁄
2
" thick for more even drying. Smaller fruits
such as grapes and cherries may be dried whole. Remove pits or
stones from fruits such as prunes, cherries, apricots, etc. Fruits that
have been artificially waxed to prevent moisture loss should always be
peeled. Peeling is optional with other fruits. Dried pear skins tend to
be grainy, and peach peels are a little fuzzy.
Most fruits can be placed directly on the drying trays as they are
prepared (pineapples, grapes strawberries, prunes, etc). However,
apples, apricots, peaches, and pears turn brown when the cut surface
is exposed to the air, due to oxidation and the continuous reaction of
enzymes. These fruits may be pretreated to slow this browning while
they are being prepared by keeping them in a holding solution until
you have sufficient fruit to pretreat.
Pretreatment
Below are listed several optional methods of pretreatment. You need
not pretreat food in order to dry it. However, pretreatment often
makes food look better, increases the shelf life and can even enhance
the nutritional value of some foods. Experiment with both treated
and untreated food in your storage to see which will best suit your
needs. Remember that proper storage is critical to the quality of the
stored product, whether treated or untreated.
Natural Pre-Dips
Use pineapple or lemon juice as a natural alternative to other
pretreatments to reduce browning. Slice fruit directly into juice.
Remove promptly (about 2 minutes) and place on trays. Fruits may
also be dipped in honey, spices, lime or orange juice, Jell-o powders
or sprinkled with coconut to give them a snappy dried flavor. Use
your imagination and make your own flavorful dip.
Guidelines for Drying Vegetables
(Cont.)
VEGETABLE
PREPARATION APPROX.
TIME
AND PRETREATMENT
IN DEHYDRATOR*
Cucumber
Wash, trim and slice about
11-13 hours
1
⁄
4
" thick.
Garlic
Separate and peel cloves.
16-18 hours
Cut cloves in halves or slice.
Mushrooms
Brush clean and remove stem.
11-13 hours
Leave whole, cut in halves
or slices.
Onions
Trim ends and peel. Cut in
13-15 hours
rings or dice.
Peppers
Wash and remove core.
13-15 hours
(Pimentos)
Cut in halves, quarters, rings
or strips.
Peppers
Wash and dry whole.
11-13 hours
(Jalapenos)
Potatoes
Wash and peel. Cut or slice as
14-16 hours
desired and steam blanch.
Rinse under cold water and
pat dry before placing on
tray(s). Note: If you wish to
leave the skin on the potatoes,
wash and scrubs with vegetable
cleaning brush then prick and
remove all "sprouts" and "scars”,
using the tip of a potato peeler
or paring knife.
Tomatoes
Wash and remove stems.
18-20 hours
Dip in boiling water and then
in cold water. Remove skin
and cut in halves, quarter
or thick slices.
Approximate times are offered as guidelines only. Drying time may
vary, depending on quality and quantity of vegetable(s) being dried.
