Copyright
©
2007 Terramite Corporation
2.5
WWW.TERRAMITE.COM/SAFETY
USA 1.800.428.3772
Intl. 1 .304.776.4231
PARTS MANUAL
Read Operators Manual For Safety
Service Operations
&
Charleston, WV/USA
When Operating the Street Sweeper
First Aid and Fire.
Keep a fire extinguisher and a first aid
kit nearby and know how to use them.
Loose Clothing.
Never take chances by wearing loose
clothing, watches or rings. Keep clothing and hands away
from moving parts.
Only Room for One.
When in operation, only the operator
should be permitted on the machine.
Mounting the Machine.
Always mount your machine
from the side. Put one foot on the machine at a time. Never
mount from the rear or while the engine is running. Before
you start the engine, always fasten the seat belt. When in
operation, do not jump either on or off the machine. Never
mount or dismount a moving machine.
Starting the Terramite Street Sweeper.
Do not attempt
to start or operate the Terramite Street Sweeper except
from the operator’s station. Never operate the controls from
the ground, as this could result in serious injury or even death.
Prevent Accidental Starting.
Disconnect the negative
wire from the battery. Put a Lock Out Tag on the machine
while being serviced. Remove key.
Other Battery Considerations.
Do not use the battery
charger as a booster to start the engine. Never disconnect
Hazards and Hazardous Areas
Approved Container.
Always use an approved container
when handling and storing diesel fuel or solvents.
When Loading Fuel.
Never fill the fuel tank while
smoking, when near an open flame or with the engine
running. Leave room for fuel expansion, 1-1/2 to 2 inches.
Replace fuel cap securely.
Cleaning Parts.
Never use gasoline or diesel fuel for
cleaning parts. Always use a nonflammable solvent.
Overhead Wires.
Watch for overhead wires and cables.
Never touch the wires with any part of the machine. If
you contact an electric line, stay on your machine until
help arrives, if you are not being shocked. If you have to
jump from the machine, make sure you are not touching
the machine as you hit the ground.
Two Men, if Possible.
When working in hazardous areas,
be extremely alert. If possible, two men should work
together, one operating the machine and the other directing
him and watching for dangers. Develop a hand signal
system or use hand signals shown on page 1.4.
Unventilated Area.
Never operate the Terramite Street
Sweeper in an unventilated area. Carbon monoxide and
methane gas are colorless and odorless.
Explosion.
Sparks can come out of the muffler or the
electrical system. Do not operate the machine in areas
where there are flammable vapors or dusts that are of the
nature that would cause an explosion.
the battery when the engine is running. Never attempt to
charge a frozen battery. An explosion may occur.
Operating at Excessive Speed.
Operating unit at
excessive speeds increases the danger of personal injury.
Do not change the governor setting or tamper with
components which may increase speed.
Excessive Hydraulic Pressure.
Do not raise the hydraulic
pressure beyond 2200 PSI. Components may become
overloaded and break, causing serious injury. This also
shortens the life of your machine.
Excessive Tire Pressure.
Never exceed maximum
recommended tire pressure, as serious injury or even death
may result.
Relief Valve Settings.
Do not change the relief valve
settings. They are factory set for the best machine
performance and safety. If it becomes necessary to adjust
this setting, refer to the Terramite Street Sweeper Service
Manual for the proper procedure.
Parking Machine.
Always park your machine on level
ground with parking brake engaged.
Prevent Fire.
Be cautious of fire when operating in dry,
dead grass or brush.
Содержание TSS46
Страница 1: ...Courtesy of Machine Market ...
