May 2015
Service Manual
Diagnostic Charts
Part No. 1265482
AL5HT
67
Engine runs but battery voltage
is low
Faulty alternator
Inspect and repair as needed.
Engine runs but lights will not
operate
Circuit breaker has tripped
Reset circuit breaker.
Loose wiring connections
Inspect and repair as needed.
Faulty generator
Inspect and repair as needed.
Lamp light output low
Dirty light fixture
Clean light fixture.
Light heads are flashing on-off Batteries low
Charge batteries.
Short in power supply cable
Inspect and repair as needed.
Power supply cable connector faulty
Inspect and repair as needed.
Light head will not illuminate
End of life
Replace lamp or light head.
Short in power supply cable
Inspect and repair as needed.
Power supply cable connector faulty or poor
connection
Inspect and repair as needed.
Unusual noise from the
generator
Generator has a faulty bearing or faulty fan
blade
Inspect and repair as needed.
Generator produces full voltage
at no load or voltage drops at
full load
Loose or broken lead wires
Inspect lead wires and connections for
broken wires and loose connections.
Rotor open or shorted
Measure resistance between leads..
Stator grounded or shorted
Contact the Genie Service
Department.
Generator voltage too high
High engine speed
Adjust the rpm
Refer to Section 2, Specifications
Generator produces no voltage
at no load or at full load
Faulty surge suppressor
Disconnect suppressor from circuit. If
there is an obvious increase in
voltage, replace the suppressor.
Faulty capacitor
Replace capacitor.
Loss of residual magnetism
Flash the rotor.
Open winding
Replace the generator.
Содержание Genie AL5HT
