13
TD-POWER MARINE
5.3
Service every 50 hours of operation
5.3.1 Change oil filter
Run the engine until it is warm. Pump up the oil through the hole for the dipstick, and
then refill with oil to the correct level. See: “Technical Data” for type of oil to be used.
Note: The oil filter should be changed at the same time as every second change of
engine oil.
5.4 Service every 100 hours of operation
5.4.1 Change oil filter
The oil filter should be changed after the first 20 hours of running, and thereafter at
every second of engine oil.
Screw off the filter and throw it away.
Coat the rubber seal of the new filter with oil.
Check the contact surface on the engine, and then screw the filter on by hand until it
is just touching the contact surface. Tighten the filter another half turn. Do not tighten
it any further.
Start the engine, let it idle and check that the oil pressure lamp goes out. Check the
oil level, and that there are no leakage around the filter.
5.4.2 Clean intake silencer
The intake silencer should be cleaned each season. Loosen the intake silencer,
wash in diesel oil and rinse thoroughly, Re-fit the intake silencer.
Generated by Foxit PDF Creator © Foxit Software
http://www.foxitsoftware.com For evaluation only.
