Sinoboom AB14EJ, Руководство по эксплуатации

Страница: 35 / 94

PRE-OPERATION INSPECTION
GTZZ14EJ&16EJ Operation Manual 5-3 © Aug 2020
Table 5-1
CUSTOMER
REQUIREMENTS
HYDRAULIC OIL
MARK
Normal-temperature region
0°C to 40°C (32°F to 104°F)
L-HV32
Cold region
-25°C to 25°C (-13°F to 77°
F)
L-HV32
High-temperature region
greater than 40°C (104°F)
L-HM68
Extremely cold region
less than -30°C (-22°F)
Special programmes
need to be identified.
NOTICE
Different hydraulic oils can be added according to
customer requirements upon factory delivery, but
cannot be mixed.
INSPECTING THE BATTERY
The condition of the battery affects the performance of
the machine. Improper levels of battery electrolyte or
damaged cable and wiring may harm battery parts and
may pose dangerous conditions.
NOTICE
Be sure to wear protective gloves before inspection.
BODILY INJURY HAZARD
Lead-acid batteries and lead-acid
maintenance-free batteries contain
acid. Avoid acid overflow or contact
with acid in lead-acid batteries and
lead-acid maintenance-free batteries.
If battery acid spills, use water mixed
with bicarbonate (baking soda) to
neutralize the acid.
• Check the acid level of the battery, if a refill is
needed, add distilled water to the inlet pipe on top of
the battery until the acid level is above the battery
plate. Do not overfill.
• Ensure the battery wiring is not corroded.
• Ensure the battery is adequately supported and the
wiring is secure.
NOTE: Add wiring end protectors and antiseptic
sealants to help eliminate corrosion of the battery
terminals and cables.
INSPECTING BATTERY
LEVEL
The battery level is identified through CAN bus
diagnostic monitor (fault display) on the turntable
controller.
Table 5-2
Battery level Description
90-100%
Full battery level
70%
Battery level 70%
50%
Battery level 50%
30%
Battery level 30%
20%
Low battery level, get charged
ASAP
10%
Very low battery level, machine
functions get slow
NOTICE
Recharge the battery when the battery charge level is
about 20%, it must be charged. Never recharge a
completely discharged battery.