1
• Pins on plug of extension cord are the same number,
size, and shape as those of plug on charger.
• Extension cord is properly wired and in good electrical
condition.
• Wire size is large enough for AC ampere rating of charger,
as specified below:
Length of cord (feet):
25
50
100
150
AWG size of cord:
18
16
12
10
11. Always charge battery in a well-ventilated area.
NEVER
operate in a closed-in or restricted area without
adequate ventilation.
WARNING:
Risk of explosive gas.
12. Locate charger as far away from battery as DC charger
cables permit.
13. Do not expose charger to rain or snow.
14.
NEVER
charge a frozen battery. If battery fluid (electrolyte)
is frozen, bring into a warm area to thaw before charging.
15.
NEVER
allow battery acid to drip on charger when reading
specific gravity or filling battery.
16.
NEVER
set a battery on top of charger.
17.
NEVER
place charger directly above battery being charged.
Gases from battery will corrode and damage charger.
18.
NEVER
touch the battery clamps together when the charger
is energized.
19.
NEVER
crank engine with charger attached to battery.
WARNING:
Battery chargers get hot during operation and
must have proper ventilation. Air needs to flow around entire
charger. Do not set on flammable items like carpeting,
upholstery, paper, cardboard, etc. Will damage leather and
melt plastic and rubber.
1.
Before you use your battery charger, be sure to read all
instructions and cautions printed on:
• Battery Charger
• Battery
• Vehicle or unit using battery
2.
Use battery charger on LEAD ACID type rechargeable
batteries only, such as used on race cars. Charger is not
intended to supply power to low-voltage electrical system
other than in an automotive application.
WARNING:
Do not use battery charger for charging dry-
cell batteries that are commonly used with home appliances.
These batteries may burst and cause injury to persons and
damage to property.
3.
Use only attachments recommended or sold by
manufacturer. Use of non-recommended attachments may
result in fire, electric shock, or injury.
4.
When disconnecting the battery charger, pull by the plug
not by the cord. Pulling on the cord may cause damage to
cord or plug.
5.
Locate battery power cord so it cannot be stepped on, tripped
over, or subjected to damage or stress.
6.
Do not operate charger with damaged cord or plug. Have
cord replaced immediately.
7.
Do not operate charger if it has received a sharp blow, been
dropped, or otherwise damaged in any way. Take it to a
qualified professional for inspection and repair.
8.
Do not disassemble charger. Take it to a qualified
professional when service or repair is required. Incorrect
reassembly may result in electric shock or fire.
9.
To reduce risk of electric shock, unplug charger from outlet
before attempting any maintenance or cleaning.
10. Do not use an extension cord unless absolutely necessary.
Use of an improper extension cord could result in fire or
electric shock. If an extension cord must be used, make
sure that:
Owner's Manual
JG-2516
25 AMP Fully Automatic Battery Charger
For 16 Volt Racing Batteries
Battery
Charger
Models:
Read Rules for Safe Operation and Instructions Carefully
Working in vicinity of a lead-acid battery is dangerous. Batteries generate explosive gases during normal
battery operation. For this reason, it is of utmost importance that each time before using your charger, you
read this manual and follow the instructions exactly.
–Save–
Important Safety Instructions
WARNING:
Handling the cord on this product or cords associated with accessories sold with this product, will expose you to lead, a
chemical known to the State of California to cause cancer and birth defects or other reproductive harm.
Wash hands after handling
.
A.
GENERAL BATTERY SAFETY
00-99-000534/0605
JEG’S HIGH PERFORMANCE
Delaware, OH 43015
Send Warranty Product Repairs to: Schumacher Electric Corporation, 1025 E. Thompson, Hoopeston, IL 60942-0280
Call Customer Service if you have questions: 1-800-621-5485
