5
Installation
Caution:
A gas appliance must
NOT
be connected to a
chimney flue servicing a separate solid fuel burning appli-
ance.
This appliance MUST be properly connected to a venting
system. This heater is equipped with a blocked vent
shutoff system designed to protect against improper vent-
ing of combustion products.
WARNING:
Operation of this heater when not connected to
a properly installed and maintained venting system or tam-
pering with the blocked vent shutoff system can result in
carbon monoxide (CO) poisoning and possible death.
Note: This appliance has a draft hood built in, and when
installed according to these instructions, the draft hood is in
the same atmospheric pressure zone as the combustion air
inlet to the appliance. Adequate combustion and ventilation
air must be provided for safe and proper operation.
The Fairfield Insert installation and venting must con-
form to the current CAN/CGA-B149 installation code (in
Canada) or the National Fuel Gas Code, ANSI Z223.1 -
1988 (in the USA), and approved per local codes. Only
qualified (licensed or trained) personnel should install
this product.
Only listed trim kits shall be used in the installation of this
appliance. Draft Relief Openings must not be covered or
blocked.
Fig. # 3
Fig. # 4
Existing Fireplace
(Masonry or Factory Built)
In order to sufficiently accommodate the Fairfield Insert, the
minimum size of the fireplace should be 25 inches wide, 18
inches high and 13 inches deep (Fig. #3 and 4). The fireplace
and its chimney should be swept and inspected. The existing
fireplace damper (if present) should be locked open or re-
moved completely if opening is too small for a 4" flue liner to
pass through.
13"
18"
25"
Minimum
Fireplace Opening
Minimum
Fireplace Opening
20
Replacement Parts
See Fig. # 40
ITEM DESCRIPTION
PART NO.
ITEM DESCRIPTION
PART NO.
1 ...... Vent Connector Assembly ............................................ FFGA.2942
2 ...... Connector Plate Strap .............................................................. 2956
3 ...... Spill Switch Wire Assembly ......................................... MINB.1699
4 ...... Spill Switch .......................................................................... 5062.1
5 ...... Baffle Assembly ........................................................... FFGA.2951
6 ...... Brick Panel, Left ............................................................... 5094.241
7 ...... Brick Panel, Back ............................................................. 5094.243
8 ...... Brick Panel, Right ............................................................ 5094.242
9 ...... Fan Cover Assembly .................................................... FFGA.2950
10 .... Burner Assembly ................................................... BRNA.2915NG
11 .... Louver Assembly, Bottom, Met. Black ................ FFGA.29611MB
........ Louver Assembly, Bottom, Porc. Blue .................... FFGA.2961BE
........ Louver Assembly, Bottom, Porc. Black ..................FFGA.2961BK
........ Louver Assembly, Bottom, Porc. Green ................. FFGA.2961GN
........ Louver Assembly, Bottom, Porc. Graphite .............. FFGA.2961GT
........ Louver Assembly, Bottom, Porc. Ivory .................... FFGA.2961IY
........ Louver Assembly, Bottom, Porc. Red .....................FFGA.2961RD
........ Louver Assembly, Bottom, Gold Plated ................. FFGA.2961GD
........ Louver Assembly, Bottom, Nickel Plated ................ FFGA.2961NI
12 .... Louver Assembly, Top, Met. Black ...................... FFGA.29601MB
........ Louver Assembly, Top, Porc. Blue .......................... FFGA.2960BE
........ Louver Assembly, Top, Porc. Black ........................FFGA.2960BK
........ Louver Assembly, Top, Porc. Green ...................... FFGA.2960GN
........ Louver Assembly, Top, Porc. Graphite ................... FFGA.2960GT
........ Louver Assembly, Top, Porc. Ivory ......................... FFGA.2960IY
........ Louver Assembly, Top, Porc. Red ...........................FFGA.2960RD
........ Louver Assembly, Top, Gold Plated ...................... FFGA.2960GD
........ Louver Assembly, Top, Nickel Plated ...................... FFGA.2960NI
13 .... Front Trim, Gold Finish (2 pcs. required)............................... 2972
........ Front Trim, Nickel Finish (2 pcs. required) ......................... 2972.1
14 .... Glass Frame .................................................................. FFGA.2970
15 .... Replacement Glass Panel .............................................. GLAS.2078
16 .... Surround Side, Left, Met. Black (*standard-size) FFGA.29771MB
........ Surround Side, Left, Porc. Blue (*standard-size) .... FFGA.2977BE
........ Surround Side, Left, Porc. Black (*standard-size) ..FFGA.2977BK
........ Surround Side, Left, Porc. Green (*standard-size) . FFGA.2977GN
........ Surround Side, Left, Porc. Graphite (*standard-size)FFGA.2977GT
........ Surround Side, Left, Porc. Ivory (*standard-size) .... FFGA.2977IY
........ Surround Side, Left, Porc. Red (*standard-size) .....FFGA.2977RD
........ Surround Side, Left, Met. Black (**over-size) ..... FFGA.29811MB
........ Surround Side, Left, Porc. Blue (**over-size) ......... FFGA.2981BE
........ Surround Side, Left, Porc. Black (**over-size) .......FFGA.2981BK
........ Surround Side, Left, Porc. Green (**over-size) ..... FFGA.2981GN
........ Surround Side, Left, Porc. Graphite (**over-size) .. FFGA.2981GT
........ Surround Side, Left, Porc. Ivory (**over-size) ........ FFGA.2981IY
........ Surround Side, Left, Porc. Red (**over-size) ..........FFGA.2981RD
17 .... Surround Side, Top, Met. Black (*standard-size). FFGA.29761MB
........ Surround Side, Top, Porc. Blue (*standard-size) .... FFGA.2976BE
........ Surround Side, Top, Porc. Black (*standard-size) ...FFGA.2976BK
........ Surround Side, Top, Porc. Green (*standard-size) . FFGA.2976GN
........ Surround Side, Top, Porc. Graphite (*standard-size)FFGA.2976GT
........ Surround Side, Top, Porc. Ivory (*standard-size) .... FFGA.2976IY
........ Surround Side, Top, Porc. Red (*standard-size) .....FFGA.2976RD
........ Surround Side, Top, Met. Black (**over-size) ..... FFGA.29801MB
........ Surround Side, Top, Porc. Blue (**over-size) ......... FFGA.2980BE
........ Surround Side, Top, Porc. Black (**over-size) .......FFGA.2980BK
........ Surround Side, Top, Porc. Green (**over-size) ...... FFGA.2980GN
........ Surround Side, Top, Porc. Graphite (**over-size) .. FFGA.2980GT
........ Surround Side, Top, Porc. Ivory (**over-size) ......... FFGA.2980IY
........ Surround Side, Top, Porc. Red (**over-size) ..........FFGA.2980RD
18 .... Surround Side, Right, Met. Black (*std-size) ....... FFGA.29751MB
........ Surround Side, Right, Porc. Blue (*standard-size) .. FFGA.2975BE
........ Surround Side, Right, Porc. Black (*std-size) .........FFGA.2975BK
........ Surround Side, Right, Porc. Green (*std-size)........ FFGA.2975GN
........ Surround Side, Right, Porc. Graphite (*std-size) .... FFGA.2975GT
........ Surround Side, Right, Porc. Ivory (*standard-size) .. FFGA.2975IY
........ Surround Side, Right, Porc. Red (*standard-size) ...FFGA.2975RD
........ Surround Side, Right, Met. Black (**over-size) .. FFGA.29791MB
........ Surround Side, Right, Porc. Blue (**over-size) ...... FFGA.2979BE
........ Surround Side, Right, Porc. Black (**over-size) .....FFGA.2979BK
........ Surround Side, Right, Porc. Green (**over-size) ... FFGA.2979GN
........ Surround Side, Right, Porc. Graphite (**over-size) FFGA.2979GT
........ Surround Side, Right, Porc. Ivory (**over-size) ...... FFGA.2979IY
........ Surround Side, Right, Porc. Red (**over-size) .......FFGA.2979RD
19 .... Surround Trim, Set (*standard-size, gold finish) .......... FFGA.2983
........ Surround Trim, Set (**over-size, gold finish) .............. FFGA.2986
........ Surround Trim, Set (*standard-size, nickel finish) ... FFGA.NITRA
........ Surround Trim, Set (**over-size, nickel finish) .. FFGA.NITROSA
........ Surround Hardware Package (met. black) ............. WINS.SMHDW
........ Surround Hardware Package (porcelain) ................ MINC.SPHDW
........ Log Set, Complete (
7 pcs. not shown
) ...................... 5097.61961.A
........ Log, Rear, #1 (
not shown
) ................................................ 5097.618
........ Log, Lower Left , #2 (
not shown
) ............................... 5097.6191.A
........ Log, Lower Right, #3 (
not shown
) .............................. 5097.6192.A
........ Log, Top Left , #4 (
not shown
) ....................................... 5097.6193
........ Log, Top Right, #5 (
not shown
) ...................................... 5097.6194
........ Log, Rear Left , #6 (
not shown
) ...................................... 5097.6195
........ Log, Rear Right, #7 (
not shown
) .................................... 5097.6196
........ Glass Gasket Kit (
not shown
) ............................................... 2078.1
* Standard-size Surround Assembly, Embossed Bevelled Panels ...................................... 37" wide x 25" high
** Over-size Surround Assembly, Plain Flat Panels .......................................................... 43" wide x 28" high
All parts may be ordered from your nearest Pacific Energy dealer. Contact Pacific Energy for the location of the dealer nearest
you.
f i r e - p a r t s . c o m
