OXE 125, Руководство пользователя

Страница: 41 / 84

35
Check fuel system
Fuel filter and water separator
!
WARNING
Discard oil and fluids according to
local environmental legislation.
– Check the fuel filter water
separator. Drain if necessary,
refer to Drain the fuel filter .
– Bleed the fuel system and
check hoses and connectors
for leakage.
!
WARNING
Turn off the engine immediately in
case of leakage.
Evacuating air from fuel system
NOTE! In order for the diesel fuel
system to work properly, the fuel
lines must be full of fuel and contain
no air. If air gets into the fuel lines,
it will be necessary to evacuate the
air from the system to eliminate the
air before operating the outboard.
Air could have entered the system in
any of the following ways:
-
The engine ran out of fuel.
– The fuel lines have damaged/
leaking joints.
-
The filter was removed for
service or replacement.
-
The fuel lines were removed or
disconnected for servicing.
-
The fuel pump was removed
for servicing.
- The fuel pre-filter water drain
cock was opened while the
engine was running.
If one or more of the above occurred,
air has entered the fuel system and
you will need to evacuate the air
from the system prior to operating
the outboard.
1.
Turn the ignition key
ON
. The
fuel pump will run for 20
seconds.
NOTE! Do not turn the ignition key
to START . This could damage the
injection pump.
2.
Repeat three times until untill
the pump is filled with fuel and
no more air is left.
Te
ch
ni
ca
l d
at
a
M
ai
nt
ena
nc
e
O
per
at
in
g
O
ve
rv
ie
w