Nordpeis NI-22, Руководство пользователя

Страница: 13 / 50

13 GB
of non-combustible material to remove the ashes. It is
recommended to leave a layer of ashes in the bottom
as this further insulates the burn chamber. Take
care with the insulation plates when the ashes are
removed, particularly when using an ash shovel, so as
not to damage them.
Thermotte® / Vermiculite Plates
These insulating plates in the burn chamber contribute
to a high combustion temperature, which leads to
cleaner combustion of the wood and a higher rate of
efficiency. Any fissures in the plates will not reduce
their insulation efficiency.
If new plates are needed, contact your dealer. Please
note: Wood logs that are too long can cause additional
strain and crack the plates, due to the tension created
between the side plates.
In case the plates need to be replaced, lift the smoke
baffle (1) in order to remove the side plates.
1. Smoke baffle*
2.
Left side plate
3.
Right side plate
* When exchanging the smoke baffle (part 1), the steel bracket
must be removed and fastened on to the new one prior to
assembly.
Door and Glass
Should there be any soot on the glass it may be
necessary to clean it. Use dedicated glass cleaner.
(NB! Be careful, detergents can damage the varnish).
If different detergents are used they may damage the
glass. A good advice for cleaning the glass is to use a
damp cloth or kitchen roll paper and apply some ash
from the burn chamber. Rub around the ash on the
glass and finish off with a piece of clean and damp
kitchen roll paper. NB! Only clean when the glass is
cold.
Check regularly that the transition between the glass
and the door is completely tight. Possibly tighten the
screws that hold the glass in place - but not too hard,
as this can cause the glass to crack. Periodically,
it may be necessary to change the gaskets on the
door to ensure that the burn chamber is air tight and
working optimally. These gaskets can be bought as a
set including ceramic glue.
Should it be necessary to unhook the door/doors,
unscrew the lid (FIG 8) above the air vent control.
The lid is fastened underneath with 3 screws / Allen
screws. When the lid is removed, the door/doors are
free to unhook.
Refractory glass should
be disposed of as resid-
ual waste, together with
pottery and porcelain
REFRACTORY
GLASS CANNOT
BE RECYCLED
Recycling of the refractory glass
Refractory glass cannot be recycled. Old glass, bre -
akage or otherwise unusable refractory glass, must be
discarded as residual waste. Refractory glass has a
higher melting temperature, and can therefore not be
recycled together with glass. In case it would be mixed
with ordinary glass, it would damage the raw material
and could, in worst case end the recycling of glass.
It is an important contribution to the environment to
ensure that refractory glass does not end up with the
recycling of ordinary glass.
7. Warranty
Read the entire user manual carefully to ensure
proper use and installation of your new Nordpeis
insert. After installation the insert should be
checked.
The inserts from Nordpeis AS benefit of a 10-year
warranty on exterior cast iron parts. The warranty
requires the insert to be installed in accordance
with applicable laws and regulations, as well as the
user manual. Notification of damage and possible
consignment of parts for replacement must be done
immediately to the retailer where the insert was
bought. Any claim must be submitted with a dated
purchase invoice or a valid warranty card.
The warranty does not include consumables such
as: Thermotte®/Vermiculite plates, smoke baffle,
glass and gaskets. Should any of the mentioned parts
break, or need to be changed due to wear and tear,
new parts can be ordered from your retailer. However,
if a material or production error can be documented
on any of the mentioned parts, the warranty is valid for
2 years after the date of purchase.
The warranty does not include damages that are
caused by wrong installation or misuse of the insert,
e.g. incorrect draught regulation or use of incorrect
fuel. The warranty does neither include interference
with operations outside the control of Nordpeis, such
as chimney draught etc. There is no compensation for
third party damage or damage to other items caused
by use of the insert.