Bayco Products, Inc. • 640 South Sanden Blvd. • Wylie, TX 75098 • USA • 1-800-233-2155 • 1-469-326-9400 • www.nightstick.com
INS-XPP-5462-16
07-26-2018
Instruction Manual
XPP-5462GX/RX Dicata™
US PATENT 9,713,217
Please read these instructions before using this product. They include
important safety and operation information.
THE XPP-5462 IS APPROVED FOR USE
CLASS I DIV 1 GRPS A-D T4
CLASS II & III DIV 1 GRPS E-G
CLASS I ZONE 0 GRP IIC T4
CLASS II ZONE 20 IIIC T135ºC
Ex ia IIC T4 Ga
DEMKO 16 ATEX 1814X
IECEx UL 16.0167X
-20ºC ≤ Tamb ≤ +40ºC
1.5V/Cell / E91 or EN91
0359
E 467756
INTRINSICALLY SAFE
SECURITE INTRINSEQUE
II 1 G Ex ia IIC T4 Ga
Bayco Products, Inc. XPP-5462
WARNINGS:
Replace batteries in a non-hazardous location.
Use only Energizer AA Model E91 or EN91 batteries.
AVERTISSEMENT:
Remplacer les piles dans une zone non dangereuse.
Utiliser uniquement les piles Energizer AA - modèle E91 ou EN91.
Ex ia FLASHLIGHT FOR USE IN HAZARDOUS LOCATIONS
Wylie, TX 75098
ID 4003544
SPECIAL CONDITIONS OF USE
y
The Nightstick XPP-5462 contains an accessible metal part with a measured
capacitance of 9.9pF. Care must be taken to avoid ignition hazards due to
potential electrostatic charging hazard.
WARNINGS - INTRINSICALLY SAFE
y
Warning: Use only the approved non-rechargeable batteries listed below.
y
Warning: Do NOT attempt to use rechargeable AA batteries with this light.
y
Warning: To prevent ignition of a hazardous atmosphere, do not open the
battery compartment in the hazardous environment. This task must ONLY be
performed in an area known to be non-hazardous.
y
Warning: When exchanging batteries, use only ENERGIZER E91 or EN91
BATTERIES.
y
Warning: To prevent ignition of a hazardous atmosphere, the AA batteries must
only be exchanged in an area known to be non-hazardous.
y
Warning: To reduce the risk of explosion, do not mix new non-rechargeable
batteries with used non-rechargeable batteries, or mix non-rechargeable
batteries from different manufacturers.
y
Warning: Substitution of components may impair intrinsic safety.
SPECIAL INSTRUCTIONS FOR INTRINSIC SAFETY
y
For personal safety, always confi rm the rating of any known hazardous or
potentially hazardous location where the light is to be used.
BATTERY INSTALLATION
WARNING: In order to maintain the XPP-5462’s Intrinsically Safe rating, the
only AA batteries certifi ed for use with this light are the ENERGIZER E91 or
EN91 BATTERIES.
y
Do not attempt to use any other brand or model of AA batteries with this light.
y
Do not attempt to use any type of rechargeable AA batteries with this light.
Warning: To prevent ignition of a hazardous atmosphere, do not open the
battery compartment door in the hazardo us environment. This task must
ONLY be done in an area known to be non-hazardous.
y
Loosen the locking screw located on the back of the battery compartment door.
NOTE: Do NOT attempt to completely remove the locking screw. Doing so is not
necessary and may damage the threads. The screw simply needs to be loosened
enough to allow the battery compartment door to open.
y
Using 3 – AA ENERGIZER E91 or EN91 BATTERIES (make sure that all 3
batteries are of the same model), install the batteries in the back of the light
paying close attention to the markings inside the battery compartment for proper
battery terminal polarity alignment.
y
Close the battery compartment door.
y
Tighten locking screw. CAUTION: Do NOT over-tighten. Doing so may damage
the threads and impact the light’s Intrinsic Safety.
OPERATION
Two switches on the front of the headlamp control all functions.
SPOTLIGHT SWITCH
y
First Press = spotlight high-brightness
y
Second Press = spotlight low-brightness
y
Third Press = off
FLOODLIGHT SWITCH
y
First Press = fl oodlight high-brightness
y
Second Press = fl oodlight low-brightness
y
Third Press = off
DUAL-LIGHT MODE
y
Press each switch one time to turn on both lights in high-brightness mode.
y
To shut down Dual-Light mode, press each switch two more times until each
light turns off.
WARRANTY
LIMITED LIFETIME WARRANTY
Bayco Products, Inc. warrants this product to be free from defects in workmanship
and materials for the original purchaser’s lifetime. The Limited Lifetime Warranty
includes the LEDs, housing and lenses. Rechargeable batteries, chargers, switches,
electronics and included accessories are warranted for a period of two years with
proof of purchase. Normal wear and failures which are caused by accidents, misuse,
abuse, faulty installation and lightning damage are excluded.
We will repair or replace this product should we determine it to be defective.
This is the only warranty, expressed or implied, including any warranty of
merchantability or fi tness for a particular purpose.
For a complete copy of the warranty, go to www.nightstick.com/nightstick-
product-support/warranties. Retain your receipt for proof of purchase.
Mode d’emploi
XPP-5462GX/RX Dicata™
Veuillez lire le mode d’emploi avant d’utiliser votre lampe frontale Nightstick
XPP-5462 à sécurité intrinsèque. Il inclut des renseignements importants
concernant la sécurité et le bon fonctionnement de votre lampe de poche.
LA LAMPE XPP-5462 EST APPROUVÉE POUR UTILISATION
CLASS I DIV 1 GRPS A-D T4
CLASS II & III DIV 1 GRPS E-G
CLASS I ZONE 0 GRP IIC T4
CLASS II ZONE 20 IIIC T135ºC
Ex ia IIC T4 Ga
DEMKO 16 ATEX 1814X
IECEx UL 16.0167X
-20ºC ≤ Tamb ≤ +40ºC
1.5V/Cell / E91 or EN91
0359
E 467756
INTRINSICALLY SAFE
SECURITE INTRINSEQUE
II 1 G Ex ia IIC T4 Ga
Bayco Products, Inc. XPP-5462
WARNINGS:
Replace batteries in a non-hazardous location.
Use only Energizer AA Model E91 or EN91 batteries.
AVERTISSEMENT:
Remplacer les piles dans une zone non dangereuse.
Utiliser uniquement les piles Energizer AA - modèle E91 ou EN91.
Ex ia FLASHLIGHT FOR USE IN HAZARDOUS LOCATIONS
Wylie, TX 75098
ID 4003544
