8 INSPECTION AND MAINTENANCE
Mitsubishi Diesel Engine S16R & S16R2 OPERATION & MAINTENANCE MANUAL
145
Pub. No. K29001-00320 Revision: 1
3
Operate the priming pump up and
down to feed fuel
• Feed fuel until the fuel free of bubbles flows
from the air vent plug, while observing the
plastic tube.
4
Remove the plastic tube connected
in Step 2, and discard fuel in the
container properly.
5
Tighten the air vent plug of the fuel
filter by turning it clockwise.
• Tool: Torque wrench
• Tightening torque:
13 to 17 N·m {1.33 to 1.73 kgf·m}
[9.59 to 12.54 lbf·ft]
Fig. 8-25 Fuel Injection Pump - Bleed Air 3
Water Separator - Check and
Service
Drain water from the water separator and replace
its element.
• The water separator is outside the
scope of our supply.
For the details, refer to the
corresponding manual of the generator
and the supplier's operation manual.
■
Water Separator - Drain Water
Drain water from the water separator.
■
Water Separator Element - Replace
1
Replace the water separator
element.
2
After the new fuel filter element is
installed, bleed air from the fuel
system.
When draining water from the water
separator, always use a container
which is suitable for the water
quantity.
* Otherwise, the drained water will overflow from
the container and may run to outside of the
facility.
* The water drained into the container is
contaminated with waste oil. Discard the water
in accordance with the local laws and
regulations as well as the manufacturer's SDS.
Drain water properly from the water
separator.
* If draining the water separator is insufficient,
water may enter into the fuel system, which
could cause damage to the devices.
Open the inlet valve of the water
separator slowly to prevent fuel in the
water separator from spilling out.
Wrap a cloth around the water
separator.
* Otherwise, spilled fuel may be ignited, which
could cause a fire.
Tighten the cover and cock on the
water separator appropriately.
* If the tightening torque is too weak, fuel may
leak, causing a fire or fuel flow-out, which could
lead to environmental pollution.
Содержание S16R
Страница 215: ......
