Mercury 6.2 TowSport MPI, Руководство по эксплуатации и обслуживанию

Страница: 73 / 87

Section 6 - Troubleshooting
90-8M0128975
eng
JUNE 2017 Page 65
Poor Performance
Possible Cause Remedy
Throttle not fully open. Inspect the throttle cable and linkages for proper operation.
Damaged or improper propeller. Replace the propeller.
Excessive bilge water. Drain and check for cause of entry.
Boat overloaded or load improperly distributed. Reduce load or redistribute load more evenly.
Flame arrestor dirty. Clean the flame arrestor.
Boat bottom fouled or damaged. Clean or repair as necessary.
Ignition problem. See
Engine Runs Rough, Misses, or Backfires
.
Engine overheating. See
Excessive Engine Temperature
.
EFI system fault. Have EFI system checked by an authorized Mercury MerCruiser dealer.
Excessive Engine Temperature
Possible Cause Remedy
Water inlet or seacock closed. Open.
Drive belt loose or in poor condition. Replace or adjust belt.
Seawater pickups or sea strainer obstructed. Remove obstruction.
Faulty thermostat. Replace.
Coolant level (if equipped) low in closed cooling section.
Check for cause of low coolant level and repair. Fill system with
proper coolant solution.
Heat exchanger or fluid cooler plugged with foreign material. Clean heat exchanger, engine oil cooler, and transmission oil
cooler (if equipped).
Loss of pressure in closed cooling section. Check for leaks. Clean, inspect, and test pressure cap.
Faulty seawater pickup pump. Repair.
Seawater discharge restricted or plugged. Clean exhaust elbows.
Insufficient Engine Temperature
Possible Cause Remedy
Faulty thermostat. Replace.
Low Engine Oil Pressure
Possible Cause Remedy
Insufficient oil in crankcase. Check and add oil.
Excessive oil in crankcase (causing it to
become aerated).
Check and remove required amount of oil. Check for cause of excessive oil
(improper filling).
Diluted or improper viscosity oil.
Change oil and oil filter, using correct grade and viscosity oil. Determine
cause for dilution (excessive idling).
Battery Will Not Recharge
Possible Cause Remedy
Excessive current draw from battery. Turn off nonessential accessories.
Alternator drive belt loose or in poor condition. Replace and/or adjust.
Unacceptable battery condition. Test battery, replace if necessary.
Loose or dirty electrical connections or damaged
wiring.
Check all associated electrical connections and wires (especially
battery cables). Clean and tighten faulty connections. Repair or
replace damaged wiring.
Faulty alternator. Test alternator output, replace if necessary.