5
6
AIR COMPRESSOR 11-GALLON (41.6 L) - 058-8386-8
AIR COMPRESSOR 11-GALLON (41.6 L) - 058-8386-8
SA
FE
TY
G
UI
DE
LI
NE
S
4.
RISK OF PERSONAL INJURY.
Never spray compressed air or material at self or others.
5.
RISK OF BURSTING.
Check the maximum pressure rating in the manual or
identification label. The compressor outlet pressure must be regulated so that it does
not exceed the maximum pressure rating. Relieve all pressure in the hose before
removing or attaching accessories.
6.
RISK OF BURSTING.
Do not adjust the pressure switch or safety valve for any reason.
They have been preset at the factory for this compressor’s maximum pressure.
Tampering with the pressure switch or the safety valve may cause personal injury or
property damage.
7.
RISK OF BURNS.
The pump and the manifold generate high temperatures. In order to
avoid burns or other injuries, do not touch the pump, the manifold or the transfer tube
while the compressor is running. Allow the parts to cool down before handling or
servicing. Keep children away from the compressor at all times.
8.
RISK TO BREATHING.
Be certain to read all labels when you are spraying paints or
toxic materials, and follow all safety instructions. Use a respirator mask if there is a
chance of inhaling anything you are spraying. Also, NEVER directly inhale the air
produced by a compressor.
9.
RISK OF EYE INJURY.
Wear ANSI Z87.1 approved safety goggles when using an air
compressor. Do not point any nozzle or sprayer toward a person or any part of the
body. Serious injury may occur if the spray penetrates the skin.
WARNING!
1.
Pull the pressure safety valve ring every day in order to ensure that
the valve is functioning properly.
2.
The compressor must be located in a well-ventilated area for
cooling, and must be a minimum of 12” (31 cm) away from the
nearest wall.
3.
Protect the air hose and the power cord from damage and puncture. Inspect them for weak or worn
spots every week, and replace them if necessary.
4.
Always wear hearing protection when using an air compressor. Failure to do so may result in
hearing loss.
5.
Do not carry the compressor while it is running.
SA
FE
TY
G
UI
DE
LI
NE
S
6.
Do not operate the compressor if it is not in a stable position.
7.
Do not operate the compressor on a rooftop or an elevated position that could allow the unit to fall
or be tipped over.
8.
Always replace a damaged gauge before operating the unit again.
Extension cords
As the distance from the supply outlet increases, you must use a heavier gauge extension cord. Using
extension cords with inadequately sized wire causes a serious drip in voltage, resulting in loss of power
and possible product damage. Refer to the table here to determine the required minimum wire size.
Recommended Minimum Wire Gauge for Extension Cords* (120 V)
AMPERE
RATING
CORD SIZE IN AWG (AMERICAN WIRE GAUGE)
Extension cord length in feet
25'
50'
75'
100'
150'
200'
0 - 5
16
16
16
14
12
12
5.1- 8
16
16
14
12
10
--
8.1 - 12
14
14
12
10
--
--
12.1 - 15
12
12
10
10
--
--
15.1 - 20
10
10
10
--
--
--
* Based on limiting the line voltage drop to five volts at 150% of the rated amperes.
The smaller the gauge number of the wire, the greater the capacity of the cord. For example, a
14-gauge cord can carry a higher current than a 16-gauge cord. When using more than one extension
cord to make up the total length, be sure each cord contains at least the minimum wire size required.
Guidelines for using extension cords
•
•
•
your
are
your
If you
using an extension cord outdoors, be sure it is marked with the
"W-A" ("W" in
Canada) to indicate it is acceptable for outdoor use.
Ensure
extension cord is properly wired and in good electrical condition. Always replace a
damaged extension cord or have it repaired by a qualified technician before using it.
Protect
extension cords from sharp objects, excess heat and damp or wet areas.
058-8386-8-Mastercraft-11G-3HP-Air-Compressor-EN-08.indd 5-6
7/4/12 11:26 AM
