HTP Drain Back, Установка, Запуск, Обслуживание, Запчасти, Гарантия

Страница: 17 / 27

lp-585 Rev. 000 Rel. 001 Date 9.10.18
17
Problem Reason Remedy
No Hot Water
1. Improper Wiring Rewire per Wiring Diagram
2. No Power - Blown Fuse or Tripped Circuit Breaker
a. Shorted Wiring
b. Circuit Overloaded
c. Improper Wiring
a. **Replace or repair
b. **Provide adequate circuit or reduce load
c. ** Rewire per diagram
3. Solar System Incorrectly Installed **Check installation
4. Leaking Plumbing or Open Hot Water Faucet(s) **Ensure all faucet(s) are closed. Check water meter
Not Enough Hot
Water
1. Heater Undersized Reduce rate of hot water use
2. Wired Incorrectly **Check wiring or replace
3. Solar System Incorrectly Installed **Check installation
Water Too Hot or Not
Hot Enough
1. Thermostat Setting Too High or Low Change setting as required
2. Thermostat Out of Calibration **Replace
3. Solar System Incorrectly Installed **Check installation
Table 5 - Troubleshooting - See Solar Water Heater Installation Manual for More Detailed Maintenance Information - ** USER - For your safety, DO
NOT attempt repair of electrical wiring, thermostat, or operating controls. Refer repairs to qualified service personnel.
The risk of scald injury increases as you increase water
temperature. Use a water tempering or mixing valve and extreme
caution when using hot water to avoid scald injury. Consult codes
for conformance. Failure to follow the instructions in this warning
statement could result in serious personal injury or death from
scalds.
Be sure to disconnect electrical power before performing service.
Failure to do so could result in electrical shock, property damage,
serious personal injury, or death.
If draining of the water heater is necessary, open the T&P valve or
a hot water tap to prevent vacuum buildup in the tank and piping.
Part 10 - System Parts Listing
A. Estimated Component Life
These water storage tanks are designed for 12 – 20 years of use.
When installed and maintained as directed by this manual, one can
expect many years of trouble-free service from this solar system.
However, all components in this system are subject to installation
conditions. For example: Where hard water is present, mineral
deposits can shorten the life of components. Periodic maintenance
as prescribed by this manual ensures that these components are
well protected from such damage.
B. Warranties and Disclaimers
NOTE:
WE EXCLUDE ANY WARRANTY FOR, OR LIABILITY FROM ACTS
OF NATURE, INCLUDING FREEZE DAMAGE.
Warranty periods for tank components are listed in the table below:
Manufacturer Item Model #
Tank
Coverage
Component
Coverage
HTP, Inc.
Drain
Back
Tank
SSU-10DB
5 (Five)
Years
1 (One) Year
Table 6 - Warranty Periods
Figure 9 - Drain Back Tank Replacement Parts