No. of
Flashes
Description
Meaning
1
Battery low
Recharge the batteries
2
Low battery
fault
The batteries have run out.
Recharge the batteries.
Check the battery and
associated wiring
3
High battery
fault
Battery voltage is too high.
Due to overcharging or steep
descent. Reduce speed if
travelling down a slope.
4
Time out or
controller too
hot
The scooter may have stalled.
The scooter off and leave for a
few minutes.
Check motor is not faulty.
5
Park brake
fault
Check the scooter is not in
freewheel mode.
Check park brake and wiring.
6
Drive inhibit
Out of neutral at power up and
battery charge connected.
Release wigwag paddle and
remove charger.
Wigwag may require
recalibration.
7
Speed Pot
Fault
Check speed pot and throttle
pot are not faulty.
8
Motor
voltage fault
Check the motor, connectors
and wiring are not faulty
9
Other error
Check all connections and wiring.
Possible controller fault.
Symptom: Horn sounds involuntarily / automatically
All upholstery can be washed with warm water
and mild soap. Occasionally check the seat and
back for sagging, cuts and tears. Replace if
necessary. Do not store your scooter in damp or
humid conditions as this will lead to mildew and
rapid deterioration of the upholstery parts.
Problem:
The scooter has diagnosed
a fault
Remedy:
Ensure the wigwag paddle
is released and switch the
scooter off and on.
Recharge batteries if error
persists.
All moving mechanisms will benefit from simple
lubrication and inspection. Lubricate using
petroleum jelly or light oil. Do not use too much
oil, otherwise small drips could stain and
damage carpets and furnishings etc. Always
perform a general inspection of the tightness of
all nuts and bolts.
ANNUAL SERVICE
We recommend the scooter is servicing by annually
by an authorized technician. Contact EV Rider to be
referred to one near you.
The scooter comes with a Dynamic 50A controller which monitors
the operation of the scooter. If a fault state occurs, then the left
most LED on the battery gauge will flash in sequence. In the event
of a fault state, count the number of flashes and refer to the table
below:
TROUBLESHOOTING
Symptom: Scooter will not switch on
Problem:
Remedy:
Battery not connected
Check batteries connected
Circuit breaker has tripped
Push circuit breaker to reset
Symptom: Scooter will switch on but will not run
Problem: Flat
Remedy: Recharge
battery Charger
battery Unplug
plugged in
charger from scooter
Motor in freewheel mode
Push down freewheel lever
Symptom: Scooter appears slow
Problem:
Flat battery
Speed setting slow
Remedy: Recharge
battery Turn up
speed dial
Symptom: Tiller appears loose or will not swivel freely
Problem:
Tiller adjustment knob loose
Remedy:
Tighten tiller adjustment
knob
