WARNING: ENGINE EXHAUST
To avoid injury from inhaling engine exhaust, always operate the
engine in a well-ventilated area. Engine exhaust is toxic.
5. Crank the engine for 20 seconds.
6. If the engine does not start, allow for a 60-second cool down and repeat
previous steps two through five. The starting cycle can be repeated up to
three times. If engine still fails to start, contact an authorized Detroit™
service outlet.
7. Once the engine has started, monitor the oil pressure gauge or warning
indicator. Keep the engine running at an idling speed until a stable oil
pressure reading of 1.2 bar (17.4 psi) or more is maintained for one minute.
8. Check for leaks. If necessary, have leaks repaired.
9. Allow the engine to reach operating temperature of 60°C (140°F).
NOTE:
Increasing engine speed above idle before oil pressure has
stabilized may cause severe engine damage.
10. Increase engine speed to 1800 rpm for three minutes.
11. Return the engine to idle and allow to idle (600 rpm) for approximately one
minute, then shut down the engine.
12. Check for leaks. If necessary, have leaks repaired.
How to Check the Lubricating Oil Level
How to Check the Lubricating Oil Level
Check the oil level daily with the engine stopped and on a level surface. If the
engine has just been stopped and is warm, wait approximately 20 minutes to allow
the oil to drain back into the oil pan before checking.
If the engine operating temperature is below 60° C (140° F), the engine must be on
a level surface and then shut down for 60 minutes for an accurate oil level reading.
Otherwise, the engine must be brought up to an operating temperature of 60° C
(140° F), parked on a level surface and then shut down for approximately 20
minutes for an accurate oil level reading.
1. Remove the oil dipstick from the guide tube. Use a clean rag to wipe off the
end of the oil dipstick.
2. Wait 15 seconds to allow any crankcase pressure to dissipate through the
guide tube and let the oil level settle in the oil pan.
Gen 5 DD Platform Operators Manual
All information subject to change without notice.
75
DDC-SVC-MAN-0217
Copyright © 2020 DETROIT DIESEL CORPORATION
