DJ Series of Rolling Jacks
22
P/N 5900258 — Rev. A — October 2020
Maintenance
⚠
WARNING:
Before performing
any
maintenance, remove air pressure from the system, then
disconnect the air pressure supply from the Air-Operated Hydraulic Pump.
To maintain your Rolling Jack
:
•
Daily
. Keep the Rolling Jack clean; wipe up any spills. Do not let dirt get into the hydraulic system.
•
Daily
. Make a visual inspection of all moving parts and check for damage or excessive wear.
Replace any damaged or worn parts before equipment is put back into operation.
•
Daily
. Make sure the Safety Locks are in good operating condition. Do not use your Rolling Jack if
the Safety Locks are damaged, excessively worn, or out of place.
•
Daily
. Inspect Lift Pads for damage or excessive wear. Replace as required with Dannmar parts.
•
Weekly
. Lubricate all rollers with general purpose oil or WD-40.
•
Weekly
. Check all Hose connections, bolts, and pins to make sure they are properly mounted.
•
Weekly
. Lubricate the Safety Lock pivot points with general purpose oil or WD-40.
•
Weekly
. Check (and tighten, if necessary) the Cylinder Bolt.
•
Every other month
. Check the Air-Operated Hydraulic Pump fluid level and refill if required.
•
As needed
. Replace all caution, warning, and safety-related labels if illegible or missing.
•
As needed
. Reorder labels and worn or damaged parts from Dannmar.
To maintain Hydraulic Fluid
:
1.
Remove the Vented Fill Cap.
2.
Insert a dipstick or piece of plastic into the tank until it hits the bottom.
3.
Remove the dipstick or piece of plastic and measure the amount of fluid.
The Hydraulic Fluid level should be from 3.35 to 3.5 inches deep.
4.
If the current level is below 3.35 inches, add Hydraulic Fluid until it is from 3.35 to 3.5 inches.
5.
Replace the Vented Fill Cap.
Содержание DJ Series
