Club Car Pioneer 900, Руководство по техническому обслуживанию

Страница: 110 / 344

TROUBLESHOOTING AND ELECTRICAL SYSTEM General Information
Page 11-2 2001 Pioneer 900 Gasoline Vehicle Maintenance and Service Manual
11
GENERAL INFORMATION
This section contains the information required to correctly troubleshoot the vehicle. A troubleshooting guide
is provided for general troubleshooting. For issues pertaining solely to the electrical system, proceed to Cir-
cuit Testing on page 11-13.
In addition to troubleshooting, this section contains general information on the electrical system and the elec-
trical circuits of the system.
TROUBLESHOOTING GUIDE
The following troubleshooting guide will be helpful in identifying operating difficulties should they occur. The
guide includes the symptom, probable cause(s) and suggested checks. The procedures used in making
these checks can be found in the referenced sections of this maintenance and service manual.
SYMPTOM POSSIBLE CAUSES REFER TO
Engine does not start easily.
Spark plug is partially fouled or in poor
condition
Section 13 – FE350 Engine
Spark plug wire is damaged or loose Section 13 – FE350 Engine
Loose wire connection at ignition coil or
RPM limiter
Section 11 – Troubleshooting and Electrical
System
Test Procedures 14, 15, and 16
Intermittent ignition coil failure
Section 11 – Troubleshooting and Electrical
System
Test Procedures 14, 15, and 16
Low cylinder compression Section 13 – FE350 Engine
Water or dirt in the fuel system
and/or carburetor;
dirty or clogged fuel filter
Section 14 – Fuel System
Carburetor improperly adjusted Section 14 – Fuel System
Starter/generator belt is slipping
Section 12 – Electrical Components
Belt Tension Adjustment on page 12-12
Engine starts but does not run
smoothly. Spark plug is fouled or in poor condition Section 13 – FE350 Engine
Spark plug wire is damaged or loose Section 13 – FE350 Engine
Intermittent ignition coil failure
Section 11 – Troubleshooting and Electrical
System
Test Procedures 14, 15, and 16
Water or dirt in the fuel system
and/or carburetor;
dirty or clogged fuel filter
Section 14 – Fuel System
Fuel pump malfunction; fuel pressure to
carburetor too low
Section 14 – Fuel System
Engine turns but fails
to start. Fuel tank is empty Section 14 – Fuel System
Fuel line or filters clogged Section 14 – Fuel System
Fouled spark plug Section 13 – FE350 Engine
Spark plug wire damaged or loose Section 13 – FE350 Engine
Troubleshooting Guide continued on next page...