Club Car Pioneer 1200, Руководство по техническому обслуживанию

Страница: 195 / 360

ELECTRICAL COMPONENTS Battery
2001 Pioneer 1200 Gasoline Vehicle Maintenance and Service Manual Page 12-33
12
Vibration Damage
The battery hold-down clamp should always be tight enough to keep the battery from bouncing. Battery life
may be severely shortened if the clamp is too loose. Excessive vibration shortens the life of the battery. It
may also cause acid to leak out of the vent caps and corrosion to build up on surrounding metal parts. The
acid which is lost reduces the capacity of the battery and cannot be replaced.
Mineral Content
For the longest battery life, distilled water should be used in the battery. However, if tap water is going to be
used, contact your local water department to be sure mineral contents are below the levels listed in the fol-
lowing table. See following NOTE.
NOTE: Contact your local water department for mineral content analysis.
Battery Removal
Read DANGER and WARNING on page 12-1 and DANGER on page 12-31.
1. Chock the wheels and release the park brake.
2. Access the engine compartment. See DANGER on page 12-1.
2.1. Tilt the bed and ensure that the prop rod is engaged.
3. Completely remove both seats from the vehicle.
4. Disconnect the battery cables, negative cable (–) first (Figure 12-1, Page 12-2).
5. Remove the four bolts, eight washers and four lock nuts from the armrests.
6. Remove the two armrests from the vehicle.
7. Carefully lift and rotate the seat support (1) 90° clockwise and allow it to rest on the vehicle body as
illustrated (Figure 12-33, Page 12-34). See following NOTE.
IMPURITY
ALLOWABLE CONTENT IN
PARTS PER MILLION
Suspended matter TRACE
Total solids 100.0
Calcium and magnesium oxides 40.0
Iron 5.0
Ammonia 8.0
Organic matter 50.0
Nitrates 10.0
Nitrites 5.0
Chloride 5.0