Club Car Carryall 300 2021, Руководство по техническому обслуживанию и ремонту

Страница: 121 / 596

PERIODIC MAINTENANCE Maintenance
10
MAINTENANCE
WARNING
• If any problems are found during scheduled inspection or service, do not operate the vehicle until
repairs are made. Failure to make necessary repairs can result in fire, property damage, severe
personal injury, or death.
• Only trained technicians should service or repair the vehicle or battery charger. Anyone doing even
simple repairs or service should have knowledge and experience in electrical and mechanical repair.
The appropriate instructions must be used when performing maintenance, service, or accessory
installation.
• Do not work on vehicle powertrain or under the cargo bed when it is loaded.
• Do not wear loose clothing or jewelry, such as rings, watches, chains, etc., when servicing the vehicle.
• Turn the key switch to OFF, remove the key, place the Forward/Reverse handle or switch in the
NEUTRAL position, and chock tires prior to servicing.
• Do not close bed until all persons are clear of the bed area. Lower the bed gently, keeping entire body
clear. Do not drop the bed. Failure to follow these instructions can result in severe personal injury.
Electric vehicles:
• Hot! Do not attempt to service hot motor. Attempting to do so can cause severe burns.
• To avoid unintentionally starting the vehicle, disconnect the batteries and discharge the controller.
Gasoline vehicles only:
• Moving parts: Do not attempt to service gasoline vehicle while the engine is running.
• Hot! Do not attempt to service hot engine or exhaust system. Failure to heed this warning can result
in severe burns.
• To avoid unintentionally starting the vehicle, disconnect battery and spark plug wire.
• Frame ground – Do not allow tools or other metal objects to contact frame when disconnecting
batteries or other electrical wiring. Never allow a positive wire to touch the vehicle frame, engine,
or other metal component.
PERIODIC SERVICE SCHEDULES
See General Warnings on page 1-1.
WARNING
• Service, repairs, and adjustments must be made per instructions in the maintenance and service
manual.
• If any problems are found during scheduled inspection or service, do not operate the vehicle until
repairs are made. Failure to make necessary repairs can result in fire, property damage, severe
personal injury, or death.
NOTE: If the vehicle is constantly hauling heavy loads or hauling a trailer, these preventive maintenance procedures
should be performed more often than recommended in the Periodic Service Schedule.
2021 Carryall 300 Maintenance and Service Manual Page 10-3