Club Car Carryall 272 2005, Руководство пользователя

Страница: 29 / 48

Maintenance
2005 Carryall 272/ Carryall 472 Gasoline Vehicle Owner’s Manual Page 27
MAINTENANCE
See General Warnings on page 10.
To ensure trouble-free vehicle performance, follow an established preventive maintenance program. Regular
maintenance can prevent vehicle downtime and expensive repairs that result from neglect. Use the Pre-Oper-
ation and Daily Safety Checklist on page 17 and the following Periodic Service Schedule and Periodic Lubri-
cation Schedule to keep the vehicle in proper working condition.
Any vehicle not functioning correctly should not be used until it is repaired. This will prevent further damage to
the vehicle and avoid the possibility of injury due to unsafe conditions.
Contact your local Club Car dealer for repairs, semiannual and annual periodic service.
∆
WARNING
• Only trained technicians should service or repair the vehicle. Anyone doing even simple
repairs or service should have knowledge and experience in electrical and mechanical repair.
The appropriate instructions must be used when performing maintenance, service, or
accessory installation.
• If any problems are found during scheduled inspection or service, do not operate vehicle until
repairs are made. Failure to make necessary repairs could result in fire, property damage,
severe personal injury, or death.
• Do not wear loose clothing or jewelry, such as rings, watches, chains, etc., when servicing
vehicle.
• Turn the key switch to the OFF position, remove the key, place the Forward/Reverse handle in
the NEUTRAL position, and chock the wheels prior to servicing the vehicle.
• Moving parts: Do not attempt to service vehicle while engine is running.
• Hot! Do not attempt to service hot engine or exhaust system. Failure to heed this warning
could result in severe burns.
• For vehicles with cargo beds, remove all cargo before raising the bed or servicing the vehicle.
If the vehicle is equipped with a prop rod, ensure that it is securely engaged. Do not close bed
until all persons are clear of cargo bed area. Keep hands clear of all crush areas. Do not drop
cargo bed; lower gently and keep entire body clear. Failure to heed this warning could result
in severe personal injury or death.
• Do not work on vehicle powertrain or under cargo bed when it is loaded.
• Turn the fuel shut-off valve to the closed (OFF) position (Figure 14, Page 25).
• To help avoid unintentionally starting the vehicle:
- Disconnect battery cables, negative (–) cable first (Figure 1, Page 9).
- Disconnect the spark plug wire from the spark plug.
• If wires are removed or replaced make sure wiring and wire harness are properly routed and
secured. Failure to properly route and secure wiring could result in vehicle malfunction,
property damage, personal injury, or death.
• Lift only one end of the vehicle at a time. Use a suitable lifting device (chain hoist or hydraulic
floor jack) with 1000 lb. (454 kg) minimum lifting capacity. Do not use lifting device to hold
vehicle in raised position. Use approved jack stands of proper weight capacity to support the
vehicle and chock the wheels that remain on the floor. When not performing a test or service
procedure that requires movement of the wheels, lock the brakes.