Club Car CARRYALL 252 2007, Руководство по техническому обслуживанию и ремонту

Страница: 507 / 536

SECTION 28 – TRANSAXLE (TYPE G): ELECTRIC VEHICLES
28
DANGER
• See General Warning on page 1-1.
WARNING
• See General Warning on page 1-1.
LUBRICATION
See General Warning on page 1-1.
There are two plugs located on the lower half of the transaxle housing. The upper plug (21) (as viewed when the
vehicle is on a level surface) is used as a lubricant level indicator
(Figure 28-5, Page 28-3) . When the vehicle
is parked on a level surface, the lubricant level should be even with the bottom of the hole. The lower plug (22) is
for draining the lubricant. When draining the lubricant, the upper plug should be removed so the lubricant will drain
faster. Be sure the drain plug is installed before filling.
See following NOTE.
NOTE: Recycle or dispose of used oil or lubricant in accordance with local, state, and federal regulations.
AXLE BEARING AND SHAFT
See General Warning on page 1-1.
AXLE SHAFT
Axle Shaft and Oil Seal Removal
1. Disconnect the batteries and discharge the controller. See Disconnecting the Batteries – Electric Vehicles,
Section 1, Page 1-4.
2. Place chocks at the front wheels. Loosen lug nuts on rear wheels and lift the rear of the vehicle with a chain
hoist or floor jack. Place jack stands under the axle tubes to support the vehicle.
See WARNING “Lift only one
end...” in General Warning on page 1-1.
3. Remove the rear wheel and brake drum. See Wheel Brake Assemblies Section and Wheels and Tires Section.
4. Use 90° internal snap ring pliers to remove the internal retaining ring (1) from the axle tube (Figure 28-1, Page
28-2) .
5. Remove the axle (2), retaining ring, and bearing assembly by pulling the axle straight out of the housing.
6. If necessary, remove the axle oil seal and adapter ring.
6.1. Use a bearing puller (CCI P/N 1016417) to remove the axle seal and adapter ring from the axle tube (Figure
28-2, Page 28-2) . See following CAUTION and NOTE.
2007-2009 Turf 252, Carryall 252 and XRT 900 Maintenance and Service Manual Page 28-1