Club Car Carryall 1500 2016, Руководство по техническому обслуживанию и ремонту

Страница: 387 / 436

HYDRAULIC ATTACHMENT SYSTEM Electrical
19
4. If switch does work as stated in previous step and the joystick still does not have power, check the following items:
– Fuse.
– Continuity of the 14-gauge red wire (w06) from the “hot” side of the circuit breaker to the fuse.
– Ccontinuity of the 14-gauge red wire (w52) from the fuse to the Accessory Relay
– Continuity of the 18-gauge red wire (w40) from the fuse to the ON/OFF switch.
– Continuity from the 14-gauge red wire (w08) at the Accessory Relay to the 16-gauge orange/black wire
(w10) at the ON/OFF switch.
– Continuity from the 16-gauge orange wire (w81) at the ON/OFF switch to any 18-gauge orange wire at
the joystick.
Joystick ON/OFF Switch Removal
1. Set the joystick ON/OFF switch to OFF and remove both seats.
2. Disconnect battery. See Side-Post Battery: Disconnecting the Battery – Gasoline/Diesel Vehicles on page
1-3.
See Top-Post Battery: Disconnecting the Battery- Gasoline/Diesel Vehicles on page 1-4.
3. Cut the wire tie securing joystick harness to chassis (Figure 19-22, Page 19-11) .
4. Access the joystick ON/OFF switch. See Joystick Removal on page 19-11.
5. Ensure the wires are connected correctly and are tight. If they are not, rewire or tighten as necessary.
6. Unplug harness from switch (Figure 19-22, Page 19-11) . Squeeze tabs at each end of switch and push switch
out the back of the control box.
Joystick ON/OFF Switch Installation
1. Insert switch into control box until fully seated.
2. Connect harness plug to switch.
3. Install control box cover/joystick assembly and secure with the four screws.
4. Secure joystick harness to chassis with new wire tie (Figure 19-22, Page 19-11) .
5. Connect battery. See Side-Post Battery: Connecting the Battery – Gasoline/Diesel Vehicles on page 1-4.
See Top-Post Battery: Connecting the Battery- Gasoline/Diesel Vehicles on page 1-4.
ATTACHMENT ARM FLOAT SWITCH
See General Warnings, Section 1, Page 1-2.
A
3
2
9
B
7
C
A. Lighted Position B. Rest Position C. Alignment Notches
Terminals:
2. #18 White w75 3. #18 Brown w20
7. #18 Light Blue w46 9. #18 Black w74
2240
Figure 19-24 Float Switch Test (Rear View)
2016 Carryall 1500/1700 and XRT 1550 Maintenance and Service Manual Page 19-13