Club Car Carryall 1500 2016, Руководство по техническому обслуживанию и ремонту

Страница: 273 / 436

ELECTRICAL COMPONENTS: DIESEL
VEHICLES Battery
14
_
IMPURITY ALLOWABLE CONTENT (PARTS PER MILLION)
Suspended matter Trace
Total solids 100.0
Calcium and magnesium oxides 40.0
Iron 5.0
Ammonia 8.0
Organic matter 50.0
Nitrates 10.0
Nitrites 5.0
Chloride 5.0
BATTERY REMOVAL
See General Warnings on page 1-2.
1. Disconnect battery. See Side-Post Battery: Disconnecting the Battery – Gasoline/Diesel Vehicles on page
1-3.
See Top-Post Battery: Disconnecting the Battery- Gasoline/Diesel Vehicles on page 1-4.
2. Remove the driver-side seat.
3. Remove the battery hold-down located on the bottom of the battery.
4. Remove the battery. See following WARNING.
WARNING
• Keep the battery in an upright position to prevent electrolyte leakage. Tipping the battery beyond a
45° angle in any direction can allow a small amount of electrolyte to leak out of the vent hole. Do not
exceed this 45° angle when lifting, carrying or installing battery. The battery acid could cause severe
personal injury when accidentally coming in contact with the skin or eyes and could damage clothing.
CHARGING THE BATTERY
See General Warnings on page 1-2.
1. Charge the battery with an automotive type 12-volt battery charger. Follow all warnings and procedures supplied
by the battery charger manufacturer.
2. Attach the charger, positive (+) cable to the positive (+) battery post and negative (–) cable to the negative (–)
battery post.
3. The battery may be charged with a slow charge (3 to 10 amps) or a fast charge (20 to 30 amps). Charge until the
specific gravity reaches 1.250.
See following WARNING.
2016 Carryall 1500/1700 and XRT 1550 Maintenance and Service Manual Page 14-23