Club Car Carryall 1 2001, Руководство пользователя

Страница: 26 / 44

Periodic Service Schedule
24 2001 Carryall Electric Vehicle Owner’s Manual
PERIODIC SERVICE SCHEDULE
REGULAR INTERVAL SERVICE
Daily Service by Owner Batteries Charge batteries (after each use only).
Weekly Service by Owner Batteries
Check electrolyte level. Add water as necessary per
the maintenance and service supplement.
See Section 13 – Batteries.
Monthly Service by Owner
or Trained Technician
Batteries
Wash battery tops and clean terminals with baking
soda/water solution. Dispose of waste water properly.
Tires
Check air pressure and adjust as necessary.
See Vehicle Capacities Chart, Page 27.
Multi-step Potentiometer (Carryall 1 vehi-
cles equipped with wiper switch style
accelerator switch). See Figure 11,
Page 25 to determine applicability.
Check for cracks or other damage; make sure switch
is securely fastened to frame. Check movable con-
tacts for correct operation.
General Vehicle
Wash battery compartment and underside of vehicle.
Dispose of waste water properly.
Semiannual Service by
Trained Technician Only
(Every 50 hours of opera-
tion).
Brake System
Check brake shoes; replace if necessary. See Sec-
tion 6 in the maintenance and service manual.
Lubricate brake slides per Lubrication Schedule. See
Section 6 in the maintenance and service manual.
Check brake cables for damage; replace as required.
Electrical Wiring and Connections Check for tightness and damage.
Forward/Reverse Switch
Check condition of contacts and wire connections;
make sure connections are tight.
Front Wheel Alignment and Camber
Check and adjust as required. See Section 7 in the
maintenance and service manual.
Motor Controller Output Regulator (MCOR)
See Figure 13, Page 25 to determine
applicability.
Check for loose hardware, cracks or other damage.
Annual Service by
Trained Technician Only
(Every 100 hours of service).
Batteries
If batteries are not performing as expected, refer to
the maintenance and service supplement, Section 13
– Batteries.
• IF ANY PROBLEMS ARE FOUND DURING SCHEDULED INSPECTION OR SERVICE, DO NOT
OPERATE THE VEHICLE UNTIL REPAIRS ARE MADE. FAILURE TO MAKE NECESSARY REPAIRS
COULD RESULT IN FIRE, PROPERTY DAMAGE, SEVERE PERSONAL INJURY, OR DEATH.
WARNING