Club Car 2009 Precedent, Руководство по техническому обслуживанию и ремонту

Страница: 96 / 312

10
Periodic Service Schedule PERIODIC MAINTENANCE
PERIODIC SERVICE SCHEDULE – ELECTRIC VEHICLES
REGULAR INTERVAL SERVICE
Pre-Operation and Daily Safety Checklist
See Pre-Operation and Daily Safety Checklist
in the appropriate Owner’s Manual
Performance Inspection
See Performance Inspection in the appropriate
Owner’s Manual
Daily service by owner
Batteries Charge batteries (after each daily use only).
Weekly service by owner
Batteries (For vehicles NOT equipped with the
Single-Point Watering System)
Check electrolyte level. Add water if
necessary. See Battery Care – Vehicles
Without the Single-Point Watering System
on page 16-17.
Batteries (For vehicles equipped with the
Single-Point Watering System). Water monthly
or according to the established watering
interval.
Water the batteries. Observe that water flow
occurs and no water overflows from any cell.
See Battery Care on page 16-16.
Batteries
Wash battery tops and clean terminals with
baking soda/water solution. Apply Battery
Terminal Protector Spray (CCI P/N 1014305)
to battery terminals.
Tires
Check air pressure and adjust if necessary.
See Section 2 — Vehicle Specifications .
Monthly service by owner or trained technician
General vehicle
Thoroughly wash vehicle including the
underside.
Initial (one-time) inspection by owner or trained
technician after six weeks of use
Batteries (For vehicles newly equipped with
the Single Point Watering System)
For vehicles newly equipped with the SPWS,
manually check battery electrolyte levels of
all cells to verify correct valve operation. See
Initial Maintenance of the SPWS on page
16-23.
Check brake shoes; replace if necessary. See
Section 6 — Wheel Brake Assemblies .
Lubricate brake system per Lubrication
Schedule. See Section 6 — Wheel Brake
Assemblies .
Brake system
Check brake cables for damage; replace if
necessary.
Electrical wiring and connections
Check for tightness and damage; replace if
necessary.
Semiannual service by trained technician only
(every 50 hours of operation or 100 rounds of
golf)
Front wheel alignment and camber
Check and adjust as required. See Section 7
— Steering and Front Suspension .
Annual service by owner or trained technician
(every 100 hours of operation or 200 rounds
of golf)
Batteries (For vehicles equipped with the
Single Point Watering System)
Manually check battery electrolyte levels of
all cells to verify correct valve operation. See
Battery Care on page 16-16.
TABLE CONTINUED ON NEXT PAGE
Page 10-4 2009 Electric Precedent Maintenance and Service Manual