SETUP
Clutch Lever
NOTE:
The distance between the clutch lever and
handgrip can be adjusted from position 1 (greatest
distance) to position 4 (smallest distance).
1. Adjust the clutch lever as per the owner’s pref-
erence.
1.1 Push the clutch lever forward to release
the adjuster dial. Hold in position.
1.2 Turn the adjuster dial to the desired posi-
tion aligning the dial number with the dot
on the lever.
1.3 Release the clutch lever.
rmo2010-001-033_a
CLUTCH LEVER ADJUSTMENT
1. Clutch lever
2. Adjuster dial
3. Dot
Suspension
ACS Rear Suspension
Models Without Compressor (Manual
Adjustment)
The suspension pressure is adjustable by deflat-
ing or inflating the air spring. Use an air compres-
sor and a pressure gauge.
To soften suspension, reduce the air pressure and
to harden suspension, increase air pressure.
1. Adjust the air spring as per the owner’s prefer-
ence.
2. Refer to the following chart for proper adjust-
ment.
MINIMUM PRESSURE 70 kPa / 10 Psi
(PAS CARGO) Kg / Lb
704904300
Kg/Lb kPa/Psi kPa/Psi kPa/Psi
kPa/Psi
kPa/Psi
380/55
450/65
515/75
550/80
585/85
345/50
415/60
480/70
515/75
550/80
310/45
380/55
450/65
480/70
515/75
70/150
70/150
45/100
0
90/200
90/200
115/250
115/250
LOAD
DRIVER
DO NOT EXCEED RECOMMENDED PRESSURE BY
70 kPa / 10 Psi
704904300
INSIDE NORTH AMERICA
MINIMUM PRESSURE 70 kPa / 0.7 bar
(PAS CARGO) Kg
704904301
Kg
380/3.80
450/4.50
480/4.80
515/5.15
480/4.80
515/5.15
550/5.50
515/5.15
550/5.50
585/5.85
345/3.45 415/4.15
450/4.50
310/3.10 380/3.80
kPa/bar
kPa/bar
kPa/bar
kPa/bar
kPa/bar
70
70
45
0
90
90
115
115
LOAD
DRIVER
DO NOT EXCEED RECOMMENDED PRESSURE BY
70 kPa / 0.7 bar
704904301
OUTSIDE NORTH AMERICA
NOTICE
Do not exceed the maximum allowed
pressure. This might damage the air suspen-
sion.
NOTE:
When adjusting the pressure, do not put
your weight on the vehicle and do not load cargo
in the storage compartment.
The air spring is connected directly to an air hose
with a manual ACS inflation valve located under
the seat.
rmo2010-001-056_a
1. Manual ACS inflation valve
NOTE:
On models equipped with a remote adjust-
ment, it is not necessary to adjust the suspension
setting. The air spring will inflate automatically at
the factory setting after the vehicle start up. Refer
to the
SPYDER RT OPERATOR'S GUIDE
for de-
tails.
42 / 52
2014-1
PREDELIVERY
