iii
CAUTIONS
Use only the supplied cords/adapters for recharging this unit. Do not recharge for
more than 3-4 hours maximum using 12 volt DC method. Recharge unit after each use.
All on/off switches should be in the OFF position when the unit is charging or not in
use. Make sure all switches are in the OFF position before connection to a power
source or load.
Never insert anything other than the supplied power/recharging cords or
recommended appliance power/recharging cords into the 12 volt DC charging/power
socket on this unit. Do not use any accessory that is not recommended or provided by
the manufacturer.
Do not use this unit to operate appliances that draw more than 5 amps.
This system is not designed to be used as a replacement for a vehicular battery. Do
not attempt to operate a vehicle that does not have a battery installed.
Although this unit contains a non-spillable battery, it is recommended that it be kept
upright during storage, use and recharging. To avoid possible damage that may
shorten the unit’s working life, protect it from direct sunlight, direct heat and/or
moisture.
Check unit periodically for wear and tear. Replace worn or defective parts
immediately; contact the Customer Service Department at (800) 618-5178.
Never submerge this unit in water, or expose it to rain or snow.
Keep unit out of reach of children (whether stored or in use).
SAVE THESE INSTRUCTIONS
ii
IMPORTANT SAFETY INSTRUCTIONS
1. When working with lead acid batteries, always make sure immediate assistance is available in case
of accident or emergency.
2. Always use protective clothing and eyewear when using this product, contact with battery acid may
cause blindness and/or severe burns. Be aware of first aid procedures in case of accidental contact
with battery acid.
3. There is a risk of explosive gases being released when lead acid batteries are being charged or
discharged. Failure to follow instructions may cause property damage, explosive hazard, and/or
personal injury.
4. Make sure the power switch is OFF before connecting battery clamps to discharged battery.
5. When charging unit from a 120 volt AC electrical outlet, in any wet or damp area, make sure that the
outlet used is protected by a ground fault interrupt (GFCI) outlet.
6. When charging the unit near water, do not allow the electrical cords and outlets to get wet; electrical
shock could result.
7. Jump-start procedures should only be performed in a safe, dry, well-ventilated area.
8. Always store battery clamps when not in use. Never touch battery clamps together – this can cause
dangerous sparks, power arcing, and/or explosion.
9. When using this unit in proximity to the vehicle’s battery and engine, stand the unit on a flat, stable
surface, and be sure to keep all clamps, cords, clothing and body parts away from moving vehicle
components.
10. Do not wear vinyl clothing when jump-starting a vehicle-friction can cause dangerous static electricity
sparks. Remove all jewelry or metal objects that could cause short circuits or react with battery acid.
11. Always disconnect the negative (black) jumper cable first: followed by the positive (red) jumper cable.
12. Never allow red and black clamps to touch each other or another common metal conductor – this
could cause damage to the unit and/or create sparking/ explosion hazard. Always store battery
clamps when not in use.
13. Do not expose battery to fire or intense heat as it may explode. Before disposing of the battery, protect
exposed terminals with heavy-duty electrical tape to prevent shorting (shorting can result in injury or fire).
14. Do not smoke, use matches or cigarette lighters while working on a vehicle’s battery system.
15. All wires, cables, and cords must be positioned so they cannot be tripped over or damaged by moving
parts, pinching or abrading.
16. NEVER ATTEMPT TO JUMP-START A FROZEN BATTERY.
Note:
Read this manual and product labeling carefully before using. Follow
recommended warnings, cautions and safety procedures; as well as
manufacturer’s guidelines for your vehicle battery.
FIRST AID
Skin:
If battery acid comes in contact with skin, rinse immediately with water, then wash thoroughly with
soap and water. If redness, pain, or irritation occurs, seek immediate medical attention.
Eyes:
If battery acid comes in contact with eyes, flush eyes immediately for a minimum of 15 minutes –
seek immediate medical attention.
Vec010BD_Manual_042905 5/9/05 1:00 PM Page ii
