12
GDO-10V2L2 Toro
™
Owner Installation Instructions
Installation
Sideroom For Left Hand Side Installation
The minimum sideroom required from the edge of
the door curtain is 127 mm to the inside of the door
bracket when the opener is mounted on the door
bracket
(Fig. 05)
.
Step 1 - Preparation
Check the door’s operation:
The door must travel smoothly and
be easy to operate by hand.
Adjust any tight or twisted guides.
Clean the guides if there is any oil or
wax present using a suitable white
spirit. The only lubricant suitable for
use on door guides is silicon spray.
DO NOT use WD-40, RP-7, petroleum
grease, or similar.
Install the locking bar covers if there are
locking bar holes in the guides.
a.
i.
ii.
iii.
b.
IMPORTANT NOTE - Do not lock your door
with the locking bars after installing the
opener. Remove or disable the lock. Security
is not affected as the opener has an inbuilt
locking facility.
Affi x the warning labels supplied with this opener in
a prominent place where they are clearly visible.
Choose the side where the opener will be installed
ensuring there is suffi cient sideroom.
Check that the door is still balanced and smooth to
operate. If it is not, the door may require servicing (refer
to door manufacturer’s instructions).
Step 2 - Fitting The Opener
At the end opposite to where the opener will be
fi tted, check that the door axle is tightened to the
bracket securely.
(Fig. 06)
Open the door completely and tie safety ropes
around the door roll approximately 300 mm from
each end. Do not tie the ropes too tight as damage
to the curtain may ensue.
At the end where the opener is to be fi tted, support
the door with a safe and suitable lifter.
WARNING! Make sure the support is snug
under the door, is stable and will not move.
At the end where the opener will be fi tted, use
pen to mark the position of the saddle on the door
bracket and the position of the door bracket on the
wall to assist in reassembling.
Remove the bolts and saddle from the door
bracket.
Remove the door bracket allowing the door to rest
on the support
NOTE - For minimum sideroom installations,
the door may have to be taken down.
WARNING! The opener must not be used with
a door incorporating a wicket door.
WARNING! The door and its springs are under
signifi cant tension. Adjustments should only
be carried out by experienced persons, as this
function can be dangerous if not performed
under strict safety procedures.
c.
d.
a.
b.
c.
d.
e.
f.
Tighten nuts
06
fi g
182
127
05
fi g
