Alliance Laundry Systems FES17AxF, Сервисная инструкция, Страница: 3 / 82

512261
1
© Copyright 2005, Alliance Laundry Systems LLC
All rights reserved. No part of the contents of this book may be reproduced or transmitted in any form or by any means without
the expressed written consent of the publisher.
© Copyright, Alliance Laundry Systems LLC – DO NOT COPY or TRANSMIT
Table of Contents
Section 1 – Safety Information
Locating an Authorized Servicer ............................4
Section 2 – Introduction
Customer Service ....................................................5
Nameplate Location ................................................5
Model Identification ................................................6
How Your Dryer Works ..........................................7
Section 3 – Troubleshooting
1. Dryer Motor Does Not Run .............................9
2. Dryer Stops In Cycle; Quits After The First Few
Loads; Has A Burning Smell; Cycles On Motor
Thermal Protector .........................................10
3. Dryer Motor Runs But Cylinder Does
Not Turn ........................................................11
4. Dryer Motor Does Not Stop ..........................11
5. Dryer Runs Only When Door is Open ...........12
6. Dryer Heating Assembly Does Not Heat or
Burner Does Not Ignite .................................12
7. Igniter Does Not Glow (Gas Supply Sufficient)
– Gas Dryer Models .......................................13
8. Burner Ignites And Goes Out Repeatedly
– Gas Dryer Models .......................................13
9. Igniter Glows But Burner Does Not Ignite
– Gas Dryer Models .......................................13
10. Dryer Heater Assembly Or Burner Shuts Off
Prematurely ....................................................14
11. Dryer Heater Assembly or Burner Repeatedly
Cycles Off On Limit Thermostat ...................14
12. Dryer Heater Assembly or Burner Does
Not Shut Off ...................................................15
13. Clothes Do Not Dry in Dryer .........................15
14. Timer Does Not Advance In Automatic
Cycle ..............................................................16
15. Clothes Are Too Hot When Removed From
Dryer ..............................................................17
16. Excessive Chattering Or Vibrating Noise
in Dryer ..........................................................17
17. Excessive Humming Or Whistling Noise
in Dryer ..........................................................17
Section 4 – Grounding
18. Ground Wires From Power Cord To Rear
Bulkhead And From Rear Bulkhead To Control
Cabinet – Check Wall Receptacle Polarity (Gas
Dryer Models Only) .......................................19
19. Ground Wire From Terminal Block To Rear
Bulkhead and From Rear Bulkhead To Control
Cabinet – (Electric Dryer Models Only) ........20
20. Stacked Dryer Ground Connections ..............21
Front Control Ground Connections ...............21
Rear Control Ground Connections .................21
Section 5 – Service Procedures
21. To Remove the Upper Dryer ..........................23
22. Control Hood Assembly
(Rear Control Dryers) ....................................24
23. Control Hood End Caps
(Rear Control Dryers) ....................................24
24. Graphic Panel (Rear Control Dryers) ............24
25. Timer (Rear Control Dryers) .........................24
26. Fabric Selector Switch
(Rear Control Dryers) ....................................25
27. Signal (Rear Control Dryers) .........................25
28. Extend Tumble Switch
(Rear Control Dryers) ....................................25
29. Control Panel and Controls
(Front Control and Stacked Dryers) ...............27
30. Access Panel ..................................................30
31. Cabinet Top ....................................................30
32. Lint Filter .......................................................32
33. Loading Door .................................................32
34. Inner and Outer Door Panels and Door Pull ..33
35. Door Strike .....................................................33
36. Reversing Door Procedure
(Doors Without Windows Only) ....................34
37. Door Seal .......................................................35
38. Front Panel and Panel Seal ............................36
39. Door Switch ...................................................36
40. Door Catch .....................................................36
41. Door Hinge .....................................................38
42. Hold-Down Clips and Locators .....................38
43. Burner System Components (Gas Models) ....39
(continued)