A.J.Antunes 9300540, Руководство пользователя

Страница: 8 / 14

MANUAL EGG COOKER/STEAMER
8 P/N 1010877 Rev. E 01/05
McDonald’s
MANUAL EGG COOKER/STEAMER
11 P/N 1010877 Rev. E 01/05
McDonald’s
TROUBLESHOOTING
WARNING
To avoid possible personal injury and/or damage to the unit, inspection, test and repair of electrical equip-
ment should be performed by qualified service personnel. The unit should be unplugged when servicing.
Problem Possible Cause Corrective Action
Unit fails to operate and
control panel lights fail
to signal on.
No power/low power. Make sure Rocker Switch (power On/Off) is ON
and power cord is locked into place. Check main
circuit breakers.
Inoperable electrical outlet. Plug into different outlet of same amperage rat-
ing.
Inoperable rocker (power On/Off)
switch.
Contact your maintenance person or an
Authorized Service Agency.
Inoperable power cord.
Loose Connections.
Unit fails to heat. Loose connections. Contact your maintenance person or an
Authorized Service Agency.
Inoperable Platen.
Low voltage.
Inoperable hi-limit thermostat.
Inoperable thermocouple.
Inoperable solid state relay.
Eggs do not cook prop-
erly.
Using refrigerated eggs and time
selector switch set for 2’ 00”.
Set time selector switch to 2’ 30” when using
refrigerated eggs.
Time selector switch is set for 2’ 30”
(eggs overcooked).
Set time selector switch to 2’ 00” when using
room temperature eggs.
Incorrect amount of water added to
trough in cover.
Fill trough in cover with water before starting time
cycle.
Platen temperature too low or high. Check Platen temperature according to the main-
tenance section of this manual.
Loose connections. Contact your Authorized Service Agency.
Unit/table is not level. Level the table and unit as necessary.
Eggs sticking to Platen. Dirty Platen. Clean Platen.
Insufficient butter being used. See the Operating Instructions section.
Eggs sticking to Egg
Rings.
Insufficient butter being used. See the Operating Instructions section.
Dirty Egg Rings. Do not use an abrasive scrubbing pad to clean
Egg Rings.
Inoperable Egg Ring. Replace Egg Ring.
Not signaling on “Bacon”
or “Ready”.
Inoperable indicator light or audio
signal.
Contact your maintenance person or an
Authorized Service Agency.
Inoperable control board.
Loose connection.
Bacon Timer is disabled. Enable Bacon Timer according to the Operating
section of this manual.
If the troubleshooting steps listed do not solve your problem, contact an A.J. Antunes Authorized Service
Agency for further assistance.