ICP N9MSE0401410A, Service And Technical Support Manual

Page: 1 / 27

Printed in U.S.A.
440 04 4401 03
Aug. 2012
SERVICE AND TECHNICAL
SUPPORT MANUAL
Single Stage, PSC Blower Motor
35” Tall, High Efficiency Condensing Gas Furnace
N9MSE (A Series)
Save this manual for future reference.
Safety Labeling and Signal Words
DANGER, WARNING, CAUTION, and NOTE
The signal words DANGER, WARNING ,
CAUTION , and NOTE are used to identify levels of
hazard seriousness. The signal word DANGER is
only used on product labels to signify an immediate
hazard. The signal words WARNING , CAUTION ,
and NOTE will be used on product labels and
throughout this manual and other manual that may
apply to the product.
DANGER − Immediate hazards which will result in
severe personal injury or death.
WARNING − Hazards or unsafe practices which
could result in severe personal injury or death.
CAUTION − Hazards or unsafe practices which
may result in minor personal injury or product or
property damage.
NOTE − Used to highlight suggestions which will
result in enhanced installation, reliability, or
operation.
!
WARNING
Signal Words in Manuals
The signal word CAUTION is used throughout
this manual in the following manner:
!
CAUTION
Signal Words on Product Labeling
Signal words are used in combination with
colors and/or pictures or product labels.
The signal word WARNING is used throughout
this manual in the following manner:
Safety − alert symbol
When you see this symbol on the unit and in
instructions or manuals, be alert to the
potential for personal injury.
TABLE OF CONTENTS
START − UP, ADJUSTMENT, AND SAFETY CHECK 4 . . . . . . . . . . .
PRIME CONDENSATE TRAP WITH WATER 4 . . . . . . . . . . . . . . . . .
PURGE GAS LINES 4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ADJUST TEMPERATURE RISE 10 . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ADJUST BLOWER OFF DELAY (HEAT MODE) 11 . . . . . . . . . . . . . .
ADJUST COOLING AIRFLOW 11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
ADJUST THERMOSTAT HEAT ANTICIPATOR 11 . . . . . . . . . . . . . . .
CHECK SAFETY CONTROLS 11 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CHECKLIST 12 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SERVICE AND MAINTENANCE PROCEDURES 13 . . . . . . . . . . . . .
RETRIEVING STORED FAULT CODES 14 . . . . . . . . . . . . . . . . . . . . .
COMPONENT SELF − TEST 14 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CARE AND MAINTENANCE 15 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
CLEANING AND/OR REPLACING AIR FILTER 15 . . . . . . . . . . . . . .
BLOWER MOTOR AND WHEEL MAINTENANCE 15 . . . . . . . . . . . .
CLEANING BURNERS AND FLAME SENSOR 17 . . . . . . . . . . . . . . .
SERVICING HOT SURFACE IGNITER 18 . . . . . . . . . . . . . . . . . . . . . .
FLUSHING COLLECTOR BOX AND DRAINAGE SYSTEM 18 . . . .
CLEANING CONDENSATE DRAIN AND TRAP 19 . . . . . . . . . . . . . .
CLEANING HEAT EXCHANGERS 19 . . . . . . . . . . . . . . . . . . . . . . . . . .
WINTERIZATION 20 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
SERVICE LABEL 21 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
WIRING DIAGRAM 22 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
TROUBLESHOOTING − FLOW CHART 23 . . . . . . . . . . . . . . . . . . . .
SEQUENCE OF OPERATION 25 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
PARTS REPLACEMENT INFORMATION GUIDE 26 . . . . . . . . . . . .
PRODUCT NOMENCLATURE 27 . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
MODELS
N9MSE0401410A
N9MSE0601410A
N9MSE0601714A
N9MSE0801716A
N9MSE0802120A
N9MSE1002114A
N9MSE1002120A
N9MSE1202420A
N9MSE1402420A
Use of the AHRI Certified TM Mark indicates a
manufacturer’s participation in the program.
For verification of certification for individual
products, go to www.ahridirectory.org .