ARTICULATE BOOM LIFT - Bil-Jax #4527A,
.
45
’ / 51’ Battery-Operated, Towable Unit
.
2015 -
“Operational and Safety Information”…
.
from;
TAYLOR RENTAL CENTER
1560 Hwy. 1 South / MLK Blvd. Greenville, MS. 38701, phone; (662) 335-3535
store hours; 7:00 am - 5:30 pm Monday thru Friday, 7:00 am - 11:00 am Saturdays
store email; [email protected], web site; taylorrentalgreenville.com
------------------------------
“
Serving the Greater Delta Area
since 1979”
-----------------------------------
Like anything else at our location, each and every piece of equipment has an inherent risk of operator error that can
.
lead to accidents and injury. An aerial work platform (AWP), like other equipment when properly used by skilled
.
operators, is relatively safe. However, should an incident happen, the chances of a catastrophic accident are greater
.
than with other equipment. This statement a
pplies to our “Bil-Jax #4727A”, Battery
.
Operated, Towable Articulated Boom Lift. We have tried to cover safety information and
.
issues as we know them at this time. With that in mind, please take a few moments to go
.
over the information printed below. These recommendations are from the equipment
.
manufacturer, the rental industry, trade magazine articles, insurance companies and our
.
own staff. We have compiled them to help to lessen the chances of accident or injury!
.
While our “Operational and Safety” information only hits a “few high point” and contains
.
“some” useful information, we strongly encourage you to take the time to read and review
.
The “complete” manufacturer’s “Operation and Safety Manual”. TRC also encourages
.
Reading and reviewing the safety publication;
Statement of Best Practices for Workplace
.
Risk Assessment and Aerial Work Platform Equipment Selection.
This booklet was
.
developed to aid the identification of workplace hazards, offer guidance for workplace
.
risk assessment and implementing control measures and assists in the selection of the
.
most appropriate AWP equipment for the work required. If you should have any questions,
.
please stop and call TRC immediately at our store location; (662) 335-3535 or after hours
.
at; (662) 822-1909 or (662) 822-
1907. Never use “any equipment” in doubt!
.
A
. MACHINE’S INTENDED USE;
This “Towable Articulate Boom Lift” is designed for lifting one or two persons with small lightweight handheld items
(in a confined length -
within the basket area). This unit may be used on “reasonable level” hard surfaces or hard
ground areas. The total weight of person or persons and small handheld items should not exceed 500 lbs. Do not
use this
equipment for anything other than what the manufacturer’s intended use. This unit is not designed to
perform crane work, nor is it designed to be used as a support structure. If you have any questions on the
manufacture’s intended use or intentions, consult with TRC or reread the manufacturer’s “Operation and Safety
Manual”! Do not alter or modify this equipment in any way. Make sure the job work is matched to the intended use,
design and ability of the machine. F
urthermore … this equipment is designed and manufactured in compliance with
the duties, responsibilities and standards set forth for manufacturers in the ANSI 92.2 standard in effect at the time
manufacturer. This equipment will meet or exceed applicable OSHA codes and ANSI A92.2 standards when used
in accordance with sections 7,8,9 & 10 of ANSI A92.2 and any other
manufacturer’s recommendations.
B
. MACHINE’S (RENTAL) DESCRIPTION;
Equipment;
TOWABLE, ARTICULATE BOOM LIFT;
(TRC computer description;
LIFT
,
BOOM ART -
TOW 45’ - 51’);
comes
equipped with the following; 1x -
Manufacturer’s “Operator’s Manual”, 4x - Hydraulic Operated Outriggers,
1x - Battery Charger.
Accessory Rental Items;
SAFETY LANYARD;
(TRC computer description;
(
LIFT,
xa item
SAFETY LANYARD
);
This is a “required item”.
We priced it separately
because some of our customers have their own safety “harness” equipment.
EXTENSION CORD;
(TRC computer description;
(
CORD,
EXTENTION 12/3 -
20’
);
is priced separately. This is used
to charge the
machine during it’s off hours. (this is the maximum length suggested by the manufacturer)
SAFETY BARRICADES and CONES;
(TRC computer descriptions;
(
SAFETY BARICADE DRUM
) and (
SAFETY CONE -
18” reflective
)
are priced separately. We strongly suggest using these if you have vehicular or pedestrian
traffic nearby.
Related Merchandise / Resale Items;
2” TRAILER BALL;
(TRC computer description;
TRAILER, TOWING BALL -
2”);
is priced separately. Customer
must use a 2” diameter with at least a 4,500 lb. or higher tow capacity.
BARRICADE SAFETY TAPE;
(TRC computer description;
SAFETY,
BARRICADE TAPE
);
is priced separately. We
offer this in a
yellow “Caution” Tape or a red “Danger” Tape. Both available in 300’ or 1,000’ lengths.
BARRICADE SAFETY FENCING;
(TRC computer description;
SAFETY, BARRICADE FENCING
);
50’ fencing is
priced separately.
C. MACHINE SPECS;
(for further information, see the Manufacturer’s “Operator’s Manual”, page; 11)
OPERATIONAL DATA;
Maximum Platform Height; 45’, Working Height; 51’. Maximum Horizontal Outreach; 27’
(from Centerline; 27’, from Outrigger Footpad Edge; 21’). Rated Platform Capacity; 500 lbs. Maximum Occupants;
2. Turntable Rotation; 700 degrees Non-Continuous. Leveling Capacity; 12.5 degrees. Localized Pressure per
Outrigger. Function Speed; Boom Raise (Fast); 30-35 seconds, (Slow); 50-55 seconds. Boom Lower (Fast);
45-50 seconds, (Slow); 120-150 seconds. Boom Extended (Fast); 30-35 seconds, (Slow); 75-90 seconds.
Turntable Rotation; (Fast); 82-90 seconds, (Slow); 100-110 seconds. Platform Level; (Fast); 8-10 seconds,
2015 - BIL-JAX #4725A,
“TOWABLE - ARTICULATE BOOM LIFT” - OPERATIONAL & SAFETY INFO
…
page 1 - 12
Summary of Contents for 4527A
Page 12: ......
