159149H
© Copyright 2018 WESCO Industrial Products, LLC. Specifications subject to change. Not responsible for errors or omissions.
Warranty Repairs
If unit does not work properly, contact your dealer or the factory (215-699-7031), within one year of purchase date.
Non-Warranty Service
For units older than one year, repairs can be made easily on site with factory supplied parts, or repairs can be made at the
factory.
NOTE: Do not send units to the factory for service without obtaining a “returned materials authorization"
(RMA) number from the service department. We will not be responsible for goods returned without proper
authorization.
To Purchase Parts
A complete parts list with drawings appears in this manual.
To order parts
contact the factory at the phone or fax numbers
WARNING: CHARGER (P/N 056762) IS SPECIALLY DESIGNED FOR USE WITH WESCO BATTERY (P/N 109102), USE
OF BATTERIES OTHER THAN WESCO'S MAY RESULT IN DAMAGE TO CHARGER, AND WILL VOID ALL
WARRANTIES.
TROUBLESHOOTING
Problem Check
Service
Required
Stacker Does Not
Operate.
(Pump Does Not Run)
Power Switch Is In "OFF" Position.
- Place in "ON" position
Battery Charger Indicator Lights.
Voltmeter Indicates 12 Volts
- Charge battery until yellow or green light is lit
Battery Terminals And Cables
- Clean if corroded (white powder).
- Tighten terminal bolts.
Hydraulic Oil Level
- Fill oil reservoir to proper level.
Stacker Does Not Lift To
Full Height.
(Pump Runs)
Oil Leaks
- Tighten fittings.
- Replace hydraulic hose if required.
Stacker Creeps Down
Under Load
Dirt In Oil Holding Valve Open
- Raise stacker to full height then lower in stages,
6" to 12" at a time to its lowest point.
- Repeat this cycle several times until dirt is
cleared and unit operates properly.
Oil Leaks
- Replace oil with clean hydraulic oil if
contaminated.
- Tighten fittings.
- Replace hydraulic hose if required.
- Replace "O" rings.
Pump Runs Continuously
Malfunctioning solenoid
- Replace pump-motor solenoid.
LIMITED WARRANTY
Wesco Industrial Products, LLC (WESCO) warrants to the purchaser of this product for a period of one year from the date of
purchase that this product shall be free of defects in material and/or workmanship, as follows:
1. WESCO will supply, at no charge, new or rebuilt replacements for any part that fails through a defect in material and/or
workmanship during the warranty period. To obtain warranty service, you must deliver the product prepaid, to the WESCO factory.
2. This warranty does not cover any product or product part which has been subject to accident, misuse, abuse or negligence.
WESCO shall only be liable under this warranty if the product is used in the manner intended by the manufacturer as specified in
the written instructions furnished with this product.
REPAIR OR REPLACEMENT AS PROVIDED UNDER THIS WARRANTY IS THE EXCLUSIVE REMEDY OF THE PURCHASER.
ANY EXPRESS WARRANTY NOT PROVIDED IN THIS WARRANTY DOCUMENT AND ANY REMEDY FOR BREACH OF
CONTRACT THAT, BUT FOR THIS PROVISION, MIGHT ARISE BY IMPLICATION OR OPERATION OF LAW, IS HEREBY
EXCLUDED AND DISCLAIMED. UNDER NO CIRCUMSTANCES SHALL WESCO BE LIABLE TO PURCHASER OR ANY OTHER
PERSON FOR ANY INCIDENTAL OR CONSEQUENTIAL DAMAGES, WHETHER ARISING OUT OF BREACH OF WARRANTY,
EXPRESS OR IMPLIED, A BREACH OF CONTRACT OR OTHERWISE. EXCEPT TO THE EXTENT PROHIBITED BY
APPLICABLE LAW, ANY IMPLIED WARRANTY OF MERCHANTABILITY AND FITNESS FOR ANY PARTICULAR PURPOSE
ARE EXPRESSLY LIMITED IN DURATION TO THE DURATION OF THIS LIMITED WARRANTY.
Some states do not allow the exclusion or limitation of incidental or consequential damages, or allow limitations on how long any
implied warranty lasts, so the above limitations may not apply to you. This warranty gives you specific legal rights, and you may
also have other rights which vary from state to state.
