11
12. W h e n p e r f o r m i n g
maintenance on this
equipment always have at
least 2 workers present. Do
not work alone in case an
emergency should arise.
13. When cleaning any parts, do not use gasoline
but use regular cleanser.
14. Always use proper tools, that are in good
condition. Make sure you understand how to
use them, before performing any service work.
2.6 BATTERY SAFETY
1. Wear gloves and safety glasses or face shield
when working on or near batteries.
2. Use a battery carrier to lift the battery or place
hands at opposite corners to avoid spilling
acid through the vents.
3. Avoid contact with battery electrolyte:
External Contact:
Flush immediately with
water.
Eye Contact:
Flush with water for 15 minutes.
Get prompt medical attention. Clean up any
spilled electrolyte immediately.
4. Avoid contact with battery posts, terminals
and related accessories, they contain lead
and lead compounds, chemicals known to
cause harm. Wash hands immediately after
handling battery.
5. Keep all sparks and flames away from batter-
ies, as gas given off by electrolyte is explo-
sive.
6. To avoid injury from spark or
short circuit, disconnect battery
ground cable before servic-
ing any part of the electrical
system.
7. FROZEN BATTERIES CAN
EXPLODE and result in death
or serious injury. DO NOT jump
start / charge a frozen battery.
Let battery thaw before charg-
ing.
8. DO NOT use or charge the battery if its fluid
level is below the LOWER mark.
2.5 MAINTENANCE SAFETY
1. Good maintenance is your responsibility. Poor
maintenance is an invitation to trouble.
2. F o l l o w g o o d s h o p
practices.
•
Keep service area
clean and dry.
•
Be sure electrical
outlets and tools are
properly grounded.
•
Use adequate light for
the job at hand.
3. Make sure there is plenty of ventilation. Never
operate the machine or the towing vehicle in a
closed building. The exhaust fumes may cause
asphyxiation.
4. Put the machine in
safe condition
before
working on this machine:
•
Flip main switch "off" or disconnect all loads
•
Shut off the engine.
•
Ensure all components have stopped moving.
5. Allow the engine to cool before performing
maintenance, engine components and oil may
be hot enough to cause injury.
6. Never work under equipment unless it is blocked
securely.
7. When performing any service or maintenance
work always use personal protection devices
such as
•
safety glasses,
•
hand protection - gloves
•
hearing protectors
• safety shoes
8. Where replacement parts are necessary for
periodic maintenance and servicing, genuine
factory replacement parts must be used to restore
your equipment to original specifications. The
manufacturer will not be responsible for injuries
or damages caused by use of unapproved parts
and/or accessories.
9. An appropriate fire extinguisher (electrical fires)
and first aid kit should be kept readily accessible
while performing maintenance on this equipment.
10. Inspect and tighten all bolts, nuts and screws
and check that all electrical and fuel connections
are properly secured to ensure generator is in
a safe condition.
11. When completing a maintenance or service
function, make sure all safety shields and devices
are installed before placing the generator in
service.
Caution:
Poison / Danger - Causes
Severe Burns. The battery contains
sulphuric acid. Avoid contact with skin,
eyes or clothing. Keep out of reach of
children.
Summary of Contents for WHS12000
Page 41: ...41...
