THERMOBILE Bio Energy 2, User Manual

Page: 21 / 91

Bio Energy series 40.020.953 - rev.
05 - 2015
21
English
4 USE
4.1 During operation
4.2 Switching off
Switch off heating:
1. Switch the rocker switch to "0".
The fuel pump stops running.
The control light turns off.
5 MAINTENANCE
5.1 Maintenance table
Use the table in this manual to record the
maintenance after each winter.
/i
Hot
Do not touch the flue stack or blower
outlet! The flue stack and blower
outlet get hot during operation!
Caution
After switching off the heater it will
run for several minutes, until the fuel
on the burner dish is used up. In the
meantime the hot air fan and the
distributor fan keep running. These
fans cool the heater until it has
sufficiently cooled down (after 10 to
30 minutes).
Both fans will stop around the same
time.
Warning
Always clean the burner dish before
starting the heater.
Description Period
Every
12
hours Week-
ly Month-
ly Every
six
months Annu-
ally Every
two
years
Clean the burner dish. X
Drain (water of) condensation from the
fuel tank, when the vegetable oil or
biodiesel contains water. X
Clean the combustion chamber. X
3. Switch the rocker switch to "2", see fig. 5
(E). The red control light is on, see fig. 5
(C).
3.4 Start up
1. Switch the rocker switch to "1", see fig. 5
(E).
When the burner dish has reached the
right temperature, the fuel pump starts
running and the control light is on.
2. During the first 20 - 30 minutes the fuel
pump should have a low capacity. The
yellow control light is on, see fig. 5 (A).