Taylor-Dunn C0-T50-80, Service And Parts Manual

Page: 81 / 135

Batteries
Page 81
MC-T50E-02
C0-T50-80
WATERING
Note: The electrolyte level in a battery rises while
charging and will be close to its highest
level after the end of a charging cycle. It is
recommended to fill the battery at the end of
a charging cycle. If the electrolyte is below
the top of the battery plates then fill just
enough to cover the plates and then top off
when the charging cycle is complete.
Clean the battery. Refer to Cleaning section for
information on cleaning the battery.
Check the electrolyte level in all battery cells. If low, fill
to the correct level (see illustration) with distilled water
using part number 77-201-00 battery filler, never add
additional battery electrolyte to the batteries.
This section is one section of a complete service
manual. Before starting any procedure, read all
warnings and instructions that are located in the
Service Guidelines chapter and beginning of this
section..
WARNING
DO NOT attempt to add electrolytes to a sealed
battery. Removing the caps of a sealed battery will
damage the battery resulting in premature failure.
NOTICE