Suzuki GA413, Service Manual

Page: 773 / 1246

BRAKES 5-1
GA413
supple
SECTION 5
BRAKES
WARNING:
For vehicles equipped with Supplemental Restraint (Air Bag) System:
Service on and around the air bag system components or wiring must be performed only by an
authorized SUZUKI dealer. Refer to AIR BAG SYSTEM COMPONENTS AND WIRING LOCATION
VIEW of GENERAL DESCRIPTION in air bag system section in order to confirm whether you are
performing service on or near the air bag system components or wiring. Please observe all
WARNINGS and SERVICE PRECAUTIONS of ON-VEHICLE SERVICE in air bag system section
before performing service on or around the air bag system components or wiring. Failure to fol-
low WARNINGS could result in unintentional activation of the system or could render the sys-
tem inoperative. Either of these two conditions may result in severe injury.
Technical service work must be started at least 90 seconds after the ignition switch is turned
to the LOCK position and negative cable is disconnected from the battery. Otherwise, the sys-
tem may be activated by reserve energy in the Sensing and Diagnostic Module (SDM).
NOTE:
For the descriptions (items) not found in this section, refer to the same section of the Service Manual
mentioned in the FOREWORD of this manual.
All brake fasteners are important attaching parts in that they could affect the performance of vital
parts and systems, and/or could result in major repair expense. They must be replaced with one of
same part number or with an equivalent part if replacement becomes necessary. Do not use a replace-
ment part of lesser quality or substitute design. Torque values must be used as specified during reas-
sembly to assure proper retention of all parts. There is to be no welding as it may result in extensive
damage and weakening of the metal.
CONTENTS
5
GENERAL DESCRIPTION 5- 2 . . . . . . . . . . . . . . . . . .
CHECK AND ADJUSTMENT 5- 2 . . . . . . . . . . . . . . . .
Stop Light Switch Adjustment 5- 2 . . . . . . . . . . . . . .
ON-VEHICLE SERVICE 5- 3 . . . . . . . . . . . . . . . . . . . .
Front Brake Hose/Pipe 5- 3 . . . . . . . . . . . . . . . . . . .
Brake Pad 5- 4 . . . . . . . . . . . . . . . . . . . . . . . . . . . . . .
Brake Stop Lamp 5- 4 . . . . . . . . . . . . . . . . . . . . . . . .