Still RX60-60, Original Instructions Manual

Page: 335 / 408

Re-commissioning after shut-
down
If the truck has been decommissioned for lon-
ger than six months, the truck must be careful-
ly checked before being recommissioned. As
with the yearly safety inspection, this check
must also include all safety-related aspects of
the truck.
–
Thoroughly clean the truck.
–
Oil joints and controls.
–
Lubricate the lubrication points.
–
Check the condition and the acid density of
the battery. Charge the battery if necessary.
–
Check the hydraulic oil for condensation
water and replace if necessary.
–
Have the same checks and tasks carried
out by the authorised service centre that
were carried out before initial commission-
ing.
–
Carry out the checks and tasks that are to
be performed before daily use.
–
Recommission the truck.
During recommissioning, the following points
in particular must be checked:
●
Drive, controller, steering
●
Brake system (service brake, parking brake,
regenerative brake)
●
Lifting system (lifting accessories, load
chains, mounting)
NOTE
For further information, see the workshop
manual for the truck and contact the author-
ised service centre.
Operating
4
Decommissioning
323 56358042501 EN - - 11