StarTrac 263-4WD-8G-STAGE-V, Owner'S Manual

Page: 69 / 100

69 | P a g e
OWNER’S MANUAL | STARTRAC 263 4WD – 8G – STAGE – V
5.30
RADIATOR FINS CLEANING
1. Periodically check to make sure that the radiator (D (Fig. 5-7) is not
clogged.
2. Clean with a jet of compressed air directed from the inside towards
the outside.
These operations must be carried out when the engine is cold.
When hot, the grilles and radiator will burn the hands and
fingers.
NOTE : The best results are obtained with a steam cleaver that softens up the dirt.
Use a lamp to check the cleaning between the radiator fins. We recommend a daily cleaning
when Tractor is used int the excess dust operation and chances of radiator chocking.
5.31 RADIATOR CAP
•
Cooling system is closed pressurized system so don't operate the
tractor without radiator cap or cap with damaged rubber
seals/defective release valve to avoid water loss and engine
overheating.
•
Use genuine radiator cap only.
5.32 CHECK OR REPLACE HOSE PIPES
•
Check hoses regularly – on every service/before cranking
tractor after long idle standing – for leaks, kinks, cuts, tears,
rubbing, bulges, corrosion, exposed fabric and other signs of
wear and damage.
•
Replace worn or damaged hoses immediately.
•
Replacement hoses are available from your dealer.
5.33 DRY TYPE AIR FILTER
Dry Air Filter Consists Of:
•
Air Filter Housing/Element
•
Clamp
•
Cover
•
Rubber Valve
•
Air Cleaner Element – Primary & Secondary Element
Discharge the dust deposits and sediments each day by pressing
the rubber valve (Fig. 5.21) on the air filter housing.
Fig.5.20
Fig.5.21
Fig.5.18
Fig.5.19