Sharp AX-1100, Service Manual

Page: 9 / 56

AX1100(R)
4 – 1
AX1100(R) Service Manual
CHAPTER 4.
PRODUCT DESCRIPTION
[1] SPECIFICATIONS
* The International Electrotechnical Commission’s standardized method for measuring output wattage. This test method is widely recognized.
[2] TEST DATA AT A GLANCE
ITEM DESCRIPTION
Power Requirements
230 Volts
50 Hertz
Single phase, 3 wire grounded
Power Consumption
Steam cooking ---- 0.91 kW Approx. 4.0A
Grill cooking --------1.1 kW Approx. 4.8A
Combi cooking ---- 2.53 kW Approx. 11.4A
Microwave cooking ---- 1.51 kW Approx. 6.8A
Off mode (Energy save mode) ---- less than 0.5 W
Microwave Power Output
*900 W nominal of RF microwave energy (IEC 60705 Test procedure)
Operating frequency 2450 MHz
Heating Element Output
Grill heating element 1.05kW
Engine heating element 0.86kW
Outside Dimensions
Width 520mm
Height 331mm
Depth 500mm
Cooking Cavity Dimensions
Width 343mm NOTE: Internal capacity is calculated by measuring maximum width, depth and height.
Height 210mm Actual capacity for holding food is less.
Depth 381mm
Weight Approx. 18.1kg
Control Complement
Manual cooking
Automatic cooking
Steam menus
Auto grill menus
Auto defrost menus
PARTS SYMBOL VALUE / DATA
Fuse F1 20A 250V
Fuse (Noise filter) F2 F8A
Thermal cut-out (Magnetron) TC1 145

C Off/ -20

C On
Thermal cut-out (Oven) TC2 170

C Off / -20

C or -35

C On
Thermal cut-out (Engine) TC3 170

C Off / -20

C or -35

C On
Thermistor (Engine) TH1 Approx. 200k

at 25

C/ Approx. 10k

at 100

C/ Approx. 1k

at 200

C,
Thermistor (Grill) TH2 Approx. 200k

at 25

C/ Approx. 10k

at 100

C/ Approx. 1k

at 200

C,
Grill heating element GH Approx. 46.5 ~ 51.1

at 25

C/ Insulation resistance > 10M

Engine heating element EH Approx. 58.0 ~ 62.9

at 25

C/ Insulation resistance > 10M

Oven lamp OL 240 - 250V 25W
High voltage capacitor C AC 2100V 1.13

F
Magnetron MG Filament < 1

/ Filament - chassis

ohm
High voltage transformer T Filament winding < 1

Secondary winding Approx. 159.5

/ Primary winding Approx. 1.98

WARNING: DISCONNECT THE PLUG WHEN MEASURING RESISTANCE
High
Low
High
Low
100 °C
70 - 95°C
-
Grill: 100% power
Microwave: 10 - 70% power
Grill: 50% power
Microwave: 10 - 70% power
0 - 100% power
0 - 35 min.
0 - 60 min.
0 - 99 min. 50 sec.
0 - 99 min. 50 sec.
0 - 99 min. 50 sec.
0 - 99 min. 50 sec.
Steam
Combi
Microwave
Grill
Temp/power range Cooking mode
YES
YES
NO
NO
NO
NO
Water tank Time range