SGMW Baojun 530, Service & Maintenance And Owner’S Manual

Page: 118 / 215

110 Driving and Controls
Driving Instructions
Vehicle Control
Do not slide in case that the engine is out of operation.
In such case, many systems (such as brake booster) cannot
function. Driving in this way will form a danger to yourself
and others.
Pedal
To ensure that the pedal travel is unhampered, the floor mat
in the pedal area shall not be excessively thick, and no
article shall be placed in the pedal area.
Emergency Measures
Caution
The operation time of the starter motor shall not
exceed 10s once. Otherwise, the starter motor will get
damaged or discharge of battery will occur.
One Tire is Punctured When the Vehicle is Running
If one tire is punctured when the vehicle is running, the
driver shall hold the steering wheel tightly to control the
driving direction, slowly decelerate, turn on the hazard
flasher, and gently depress the brake pedal to park your
vehicle in a safe area.
Warning
Do not brake suddenly when one tire is punctured.
Braking suddenly will cause the vehicle to tilt towards
one side, and thus an accident may be caused.
One Fault Exists When the Vehicle is Running
If one fault exists when the vehicle is running, the driver shall
turn on the hazard flasher, slowly decelerate, and park the
vehicle in a safe area at the curb.
Place a warning triangle at a position 50 m behind the
vehicle in the daytime while placing it at a position 100 m
behind the vehicle at night. Please follow requirements of
traffic laws and regulations.
After inspection, send the vehicle to the Aftersales Service
Center for inspection and maintenance.
Place the warning triangle in the luggage compartment, or
have the customer give it to you when the vehicle is being
delivered.
If the Engine Does Not Work
In case that the ignition switch is at the START position, if
the starter motor does not work, please check whether the
battery is dead, whether the battery port is connected
correctly and whether relevant fuses get damaged.
If the starter motor works but the engine fails to be started,
please check fuel level, fuel filter, fuel pump, relevant wiring,
etc.
The operation condition of the fuel pump can be
preliminarily judged by hearing sounds made by the ignition
switch when it is being turned on.
Measures Taken in Case of Engine Overheat
When the vehicle is running, if the output power of the
engine reduces suddenly or the warning lamp on the
instrument
indicating excessively high temperature
illuminates, park your vehicle in a safe area and take
following measures:

Have the engine run at idle, and turn the transmission
at the neutral position.

Pull the parking brake lever.

Turn off the A/C.

Open the bonnet to ventilate the engine bay.

If the level of the coolant reservoir does not drop, stop
the engine to cool it.

If the coolant level is very low, uncover the reservoir,
slowly fill water in the reservoir drop by drop till the
level reaches the MAX (maximum) level mark of the
coolant reservoir.

After taking provisional measures, immediately send
the vehicle to the Aftersales Service Center for
inspection.
Warning
Do not open the bonnet if steam or coolant overflows
from engine parts. Otherwise, you may be scalded by
steam or coolant.