Multi Voltage glow Plug tester
Model no:
Vs270
thank you for purchasing a sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT:
PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. safety
warNiNg!
ensure Health and Safety, local authority and general workshop practice regulations are adhered to when using tools.
9
Maintain tester in good and clean condition for best and safest performance.
9
Wear approved eye protection. A full range of personal safety equipment is available from your Sealey stockist.
9
Wear suitable clothing to avoid snagging.
Do Not
wear jewellery and tie back long hair.
9
Account for all tools and parts being used and
Do Not
leave any in or near the engine.
8
Do Not
use tester if damaged.
9
Vehicle should be in a well ventilated area.
iMPortaNt:
These instructions are provided as a guide only. Always refer to the vehicle manufacturer’s service instructions, or a
proprietary manual, to establish the current procedure and data.
warNiNg!
The warnings referred to in this guide cannot cover all possible conditions and situations that may occur. It must be
understood that common sense and caution are factors which cannot be built into this product, but must be applied by the operator.
2. iNtroDuctioN
designed to test low voltage glow plug operation on modern diesel engines. Prevents glow plug damage caused by testing with the vehicle
battery. Glow plugs can be tested whist in situ. Supplied in storage case with instructions. Requires 9V battery (not supplied).
3. oPeratioN
3.1.
To fit the battery remove rubber case, the battery compartment is located on the base of back of the unit.
3.2.
Multi Voltage glow Plug tester
3.2.1.
Many modern diesel engines have low voltage glow plugs fitted, this type of glow plug cannot be tested using the vehicle battery
voltage as damage may occur.
VS270 Issue 1 06/11/19
Original Language Version
© Jack Sealey limited
Refer to
instructions
Wear eye
protection
Wear protective
gloves
Wear safety
footwear
Wear protective
clothing
