FOUR-WHEEL LASER WHEEL ALIGNER
MODEL NO:
GA70.V2
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these
instructions, and properly maintained, give you years of trouble free performance.
IMPORTANT:
PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
1.1
GENERAL SAFETY
WARNING!
Ensure Health & Safety, local authority, and general
workshop practice regulations are adhered to when using this
equipment.
9
Maintain the
wheel aligner in good condition (use an authorised
service agent).
9
Replace or repair damaged parts.
Use genuine parts only.
Non-authorised parts may be dangerous and will invalidate the
warranty.
9
Locate wheel aligner in a suitable working area, keep area clean
and tidy and free from unrelated materials.
WARNING!
Use aligner on vehicles that are parked on level and
solid ground.
9
Keep the gauge clean to ensure accurate performance.
8
DO NOT
use outside in damp or wet weather conditions.
8
DO NOT
allow untrained persons to operate the aligner.
8
DO NOT
leave the aligner unattended.
WARNING!
When setting front end alignment on commercial
vehicles never make adjustments to drop arms or interconnecting
links. Doing so could result in serious tyre, wheel and steering
problems.
WARNING!
The warnings, cautions and instructions contained within this
document cannot cover all possible conditions and situations that may occur. It
must be understood that common sense and caution are factors which cannot be
built into this product, but must be applied by the operator.
9
Any alignment changes deemed necessary as a result of using this equipment
must be made strictly in accordance with the vehicle manufacturer’s
recommendations.
1.2
LASER SAFETY
The
GA70
utilises a Class II laser that emits low levels of visible radiation (i.e.
wavelengths between 400 and 700 nanometres) which are safe for the skin but
not inherently safe for the eyes. The Class II emission limit is set at the
maximum level for which eye protection is normally afforded by natural aversion
responses to bright light. Accidental eye exposure is therefore normally safe,
although the natural aversion response can be overridden by deliberately staring
into the beam, and can also be influenced by the use of alcohol or drugs.
WARNING!
DO NOT
look or stare into the laser beam as permanent eye
damage could result.
8
DO NOT
direct the laser beam at any person’s (or animal’s) eyes as eye damage
could result. If the beam is obstructed by a person during use, release the
contact switch immediately.
8
DO NOT
use the equipment while under the influence of alcohol, drugs or whilst
on medication.
9
Be aware that reflections of the laser beam from mirrors or other shiny surfaces
can be as hazardous as direct eye exposure.
2. INTRODUCTION
Fast, simple and accurate alignment of both front and rear wheels. Optimises vehicle
performance and set up after installation or modification of steering and suspension
components. Simple and fast to use, it is ideal for the busy professional workshop
and has a fast return on investment - potentially adding value to every steering or
suspension job. This fully portable kit is also ideal for track-day set up for the enthusiast.
Works on practically all cars and light commercials with rim diameters between
330mm(13”) and 560mm(22”). Supplied with steering wheel clamp, wheel turn plates
and wheeled storage rack and comprehensive operating instructions.
GA70.V2 | Issue 2 06/06/2019
Original Language Version
© Jack Sealey Limited
Refer to
instructions
Wear protective
gloves
Wear safety
footwear
Wear protective
clothing
Keep in dry area
protect from rain
Warning
laser beam
The GA70.V4 kit consists of: Mobile storage unit (see below)
1. Laser Measuring Head
X2
4. Dished Turning Plate
X2
2. Alignment Assembly Flags
X2
5. Extension Bobbins
X6
3. Steering Wheel Clamp
X1
6. 13” Wheel Spacers
X4
