10.8V Ø75MM CORDLESS POLISHER - BODY ONLY
MODEL NO:
CP108VCPBO
Thank you for purchasing a Sealey product. Manufactured to a high standard, this product will, if used according to these instructions,
and properly maintained, give you years of trouble free performance.
IMPORTANT:
PLEASE READ THESE INSTRUCTIONS CAREFULLY. NOTE THE SAFE OPERATIONAL REQUIREMENTS, WARNINGS & CAUTIONS. USE
THE PRODUCT CORRECTLY AND WITH CARE FOR THE PURPOSE FOR WHICH IT IS INTENDED. FAILURE TO DO SO MAY CAUSE DAMAGE AND/OR
PERSONAL INJURY AND WILL INVALIDATE THE WARRANTY. KEEP THESE INSTRUCTIONS SAFE FOR FUTURE USE.
1. SAFETY
9
Disconnect the polisher from the battery unit before changing accessories, servicing or performing any maintenance.
9
Maintain the polisher and battery in good condition. Check moving parts alignment on a regular basis.
9
Replace or repair damaged parts. Use an authorised service agent and recommended parts only. Unauthorised parts may be
dangerous and will invalidate the warranty.
9
Ensure the polisher is switched off before installing the battery pack.
9
Keep the polisher and charger clean for best and safest performance.
9
Remove ill fitting clothing. Remove ties, watches, rings and other loose jewellery and contain long hair.
9
Evaluate your working area before using the polisher e.g. ceilings, floors and enclosures may contain electrical items or water piping.
9
Ensure battery pack is correctly inserted into the polisher handle and latched in place before attempting to switch on polisher.
9
Secure loose work pieces with a clamp, vice or other adequate holding device.
9
Avoid unintentional starting.
9
Wear approved safety eye protection (standard spectacles are not adequate).
9
Maintain correct balance and footing. Ensure the floor is not slippery and wear non-skid shoes.
9
Keep children and unauthorised persons away from the working area.
9
Store polisher and charger in a safe, dry, childproof area where the temperature will not exceed 104°F (40°C).
8
DO NOT
use the polisher where there are flammable liquids, solids or gases, such as paint solvents, etc.
8
DO NOT
allow children to operate the polisher.
8
DO NOT
operate the polisher if any parts are missing as this may cause failure and/or personal injury.
8
DO NOT
hold unsecured work piece in your hand.
8
DO NOT
leave the polisher operating unattended.
8
DO NOT
carry the polisher with your finger on the power switch.
8
DO NOT
use the polisher for a task it is not designed to perform.
8
DO NOT
operate the polisher when you are tired or under the influence of alcohol, drugs or intoxicating medication.
8
DO NOT
get the polisher or battery wet or use in damp or wet locations.
2. INTRODUCTION
C
ompact, lightweight cordless polisher - body only. Comfortable housing with soft grip to help reduce vibration. Variable speed control trigger makes
this polisher very easy-to-use. Supplied with side handle and polishing pad. Requires compatible 10.8V 2Ah or 4Ah battery and mains charger, sold
separately.
3. SPECIFICATION
Model No. .......................................................
CP108VCPBO
B
attery ..................
10.8V 2Ah-4Ah Lithium-ion (not included)
Consumable parts (not included)
..........................................................
CP108VBP 2Ah Battery
........................................................
CP108VBP4 4Ah Battery
Free speed ..........................................
0-2600rpm/0-7800rpm
Noise power/pressure ..........................................
91/80dB(A)
V
ibration/rating ..............................................
4.7m/s²/1.5m/s²
Pad size ....................................................................
Ø75mm
Replacement parts .....................
CP108VMC - Mains charger
Thread size .......................................................................
M6
4. OPERATION
4.1.
Fit battery.
4.2.
BATTERY CHARGE STATUS TEST
4.2.1.
Press trigger, all LEDs lit: battery charged, one LED lit: battery needs
charging.
4.3.
In order to maintain battery efficiency:
8
DO NOT
fully discharge. After every use fully charge the battery, charge every 4 months even if tool is not used.
Original Language Version
© Jack Sealey Limited
Refer to
instruction
manual
Wear protective
gloves
Wear eye
protection
Wear face
mask
Wear ear
protection
fig.1
C
P108VCPBO Issue 2 (3) 06/06/22
