Warnings and Cautions – Working with Compressed Air
xix
SCOTT SAFETY
087-0067 REV A
Warnings and
Cautions – Working
with Compressed Air
Ensure you follow the applicable warnings and cautions indicated here.
Warning: Before use, this equipment must be properly installed and inspected by a
Scott Safety trained and certified technician. Do not operate if the equipment has not
been prepared by a Scott authorized service technician. Use of this equipment without
proper set up may result in serious personal injury, death, or permanent equipment
damage.
Warning: Training is required before use of this equipment. Improper use of this
equipment may result in serious injury or death. Improper use includes, but is not
limited to, use without adequate training, disregard of the warnings and instructions
contained herein and failure to inspect and maintain this equipment.
Warning: If any air leak is noted, or the equipment does not operate as described in
this manual, immediately terminate its use and consult with a certified service
technician before proceeding. Use of malfunctioning equipment may create
circumstances resulting in serious personal injury or death.
Warning: The misuse of compressed air can cause severe injury or death. Take every
precaution in the use of compressed air. Always remember to release all residual air
pressure from the compressor system before repairing or doing maintenance work.
Caution: Perform all pre-operation checks prior to starting the unit. Establish and
maintain a pre-operation inspection procedure for the compressor and related
accessories. Routine inspection of the equipment is the responsibility of the
organization using the equipment, and must be in accordance with technical and
service guidelines provided by Scott Safety.
Warning: Never tighten, loosen, or adjust any type of fitting that is under pressure.
Warning: The compressor contains hot surfaces. To reduce the risk of burns, do not
touch.
Caution: There is a risk of bursting. Do not adjust regulator to result in output
pressure greater than marked maximum pressure of attachment.
Warning: There is a risk of injury. Do not direct air stream at body.
Caution: To reduce the risk of electric shock or injury, use indoors only.
Caution: Use only recommended air-handling parts acceptable for pressure not less
than 7,300PSI since there is a risk of bursting.
Warning: Never adjust a safety relief valve. Interfering with system settings can result
in serious damage or injury.
Summary of Contents for HushAir Connect 7500
