Schulte 2 Series, Operator'S Manual

Page: 14 / 182

SAFETY
FX1800/FX1200 07/20 Safety Section 1-4
© 2020 Alamo Group Inc.
SA
FE
TY
CRUSHING HAZARDS
TO AVOID DEATH OR SERIOUS INJURY FROM FALLING OFF TRACTOR, EQUIPMENT RUN OVER,
ROLLOVER AND CRUSHING BY FALLING WING OR IMPLEMENT:
•
USE ROPS
and
SEAT BELT
equipped tractors for mowing operations.
•
KEEP ROPS
lock in up position.
•
ALWAYS BUCKLE UP
seat belt when operating tractor and equipment.
•
ONLY OPERATE
tractor and equipment while seated in tractor seat.
•
IN CASE OF EMERGENCY
, shut down tractor engine, disengage the PTO and wait for all rotating motion to stop. Place the tractor
in park position, engage the parking brake and remove the key before leaving the operator’s seat.
WHEN RAISING OR LOWERING WINGS:
• Raise or lower ONLY WHILE SEATED in tractor seat with seat belt buckled.
• Raise or lower ONLY when implement tongue is securely attached to tractor drawbar TO AVOID implement tip over.
• KEEP BYSTANDERS CLEAR of area TO AVOID crushing.
• KEEP sufficient clearance around implement and wings TO AVOID contacting buildings or overhead power lines.
LIFTED Equipment can fall from mechanical or hydraulic failure or inadvertent Control Lever movement.
TO AVOID EQUIPMENT FALLING while working near or under lifted wings, components and
implements raised by 3-Pointed tractor hitch:
• SECURELY SUPPORT or block up raised equipment, wings and components.
• BLOCK UP and securely support equipment before putting hands, feet or body under raised equipment or lifted compo -
nents.
• KEEP BYSTANDERS CLEAR of folded wings until wings are blocked or locked up.
WHEN PARKING Implement and Tractor:
•
LOWER
implement,
LOCK
or
BLOCK
lifted parts before leaving equipment.
•
NEVER
leave implement unattended in a raised position.
TO AVOID CHILDREN FALLING OFF OR BEING CRUSHED BY EQUIPMENT:
• NEVER ALLOW children to play on or around Tractor or Implement.
WHEN UNHITCHING IMPLEMENT:
•
LOWER
implement,
LOCK
or
BLOCK
lifted parts before leaving equipment.
•
USE
tongue jack to control implement tongue movement.
•
USE
tongue
JACK
to lift heavy implement tongues.
•
AVOID
overloading jack to prevent jack failure and injury. (Refer to Instructions in Operation Section)
BEFORE REMOVING Wing Retaining Lock:
• ATTACH hoses to tractor.
• FILL Wing Cylinders with oil. (Refer to Instructions in Operation Section)
• KEEP bystanders away before operating wings.
• LOWER WINGS slowly and carefully.
PN CH01