请注意此使用说明书必须送
至最终用户和维修责任者手
中保管。
This manual should be given to
the person who actually uses the
products and is responsible for
their maintenance.
B A B
接地金属
Groun
d
plate
接地金属
Groun
d
plate
上面列出的型号后缀带* 的产品,有关该产品规格的详细信息,请参阅样本。
Suffixes listed below may be attached to the above types at portions marked with * . For
details regarding specifications, see the catalog.
*1 : J
能效值
型号
吸持功率(VA)
能效等级
CK3-105J
20.0
2
CK3-105,125,150,125J,150J
10.0
2
CK3-180,220,300,400,180J,220J
13.0
2
CK3-600
15.0
2
安全注意事项
在安装、运行、保养和维修前必须熟读使用说明书,以保证正确使用。
使用说明书中对安全注意事项区分为“警告”
、
“注意”两个等级。
:不解除的话, 有可能造成死亡或重伤的危险状态
:不解除的话, 有可能造成中等程度的残疾, 轻伤以及发生物质损伤事故。
并且,即使在 中记载的事项根据情况也有可能导致发生重大事故,所以记载
内容都很重要,请必须遵守。
1.
解开包装
(1)
请确认产品型号、控制线圈电压及适用容量与要求的规格是否一致。
(2)
请检查是否有由于运输等原因而引起的零部件松动或破损现象。
2.
保管
请避免高温多湿、有腐蚀性气体及日光直射的场所,以原包装的状态进行保管。
3.
安装
(1)
请安装于干燥、洁净、牢固的场所。
(2)
请垂直安装。允许倾斜角度在 30°以内。(Fig.1)
4.
安装空间(Fig.2,3)
(1)
安装间隙需在 Table 1 尺寸以上。
(2)
紧密安装时(连续通电和高频通断的产品视同紧密安装),根据使用条件有可
能因温度上升而造成线圈寿命降低。在此种条件下使用时,推荐使用时产品
间的间距大于 20mm。
(3)
C 尺寸是在 IEC 标准及 GB 标准的接通、分断容量试验条件下的值。
Safety Precautions
To ensure proper use of the product, be sure to read this manual and the other attached
documents carefully before starting installation, operation, maintenance and inspection. Within
this instruction manual, safety precautions are ranked, in order of importance, as either“Warning”
or “Caution”.
Indicates a potentially hazardous situation, which, if not avoided, could result in
death or serious injury.
Indicates a potentially hazardous situation, which, if not avoided, may result in
minor or moderate injury and/or damage to the equipment.
Under certain conditions, improper operation may result in serious injury and/or damage even if it
is labeled only as “Caution”. Every item indicated by either “Warning” or “Caution” should be
considered significant. Be sure to give particular care to those items.
1. Unpacking
(1) Check that the type, coil voltage and contact arrangement match the requested specifications.
(2) Make sure that no parts have been lost or damaged.
2. Storage
Store the unit in the packing box. Do not store the packing box in a location subject to high
temperature, high humidity, corrosive gas, or direct sunlight.
3. Mounting
(1) Mount in a dry, clean and stable location.
(2) Mounting on a vertical surface. The product must not incline more than 30゜. (Fig.1)
4. Mounting space(Fig.2, 3)
(1) Mount the products at a distance of at least that shown in the Table 1.
(2) When units must be installed very closely, the temperature may rise in some conditions (i.e. the
power is continuously supplied for a long time or units that frequently do switching are
installed very closely), and it may shorten the life of the coil. Thus, when installing units very
closely, it is recommended to install the units 20 mm or more apart.
(3) Dimension C is based on breaking test in close circuit of IEC and GB standard.
交流接触器
Magnetic Contactor
Type
CK3-105*1
CK3-125*1
CK3-150*1
CK3-180*1
CK3-220*1
CK3-300
CK3-400
CK3-600
CK3-800
警告
●
请不要触摸和靠近通电中的产品,因有触电、灼伤的危险。
●
维修、检验请在切断电源后进行,因有触电的危险。
注意
●
因为有引发灼伤、火灾的可能,所以请确保说明书上规定的安装空间。
●
因为有引发火灾的可能,所以请在接线时按额定电压、通电电流选用符合规范尺寸
的电线,紧固螺钉按照使用说明书规定的力矩紧固。
●
请不要在切断电源后立即触摸产品,因为余热可能会导致灼伤。
●
请不要在打开消弧盖的情况下使用,因为有引发触电、灼伤的可能。
●
产品废弃时需按产业废弃物处理。
Table 1
Type
A
[mm]
B
[mm]
C
[mm]
CK3-105
9
12
2
CK3-125
0
10
2
CK3-150
4
10
2
CK3-180
3
10
2
CK3-220
3
10
2
CK3-300
19
22
2
CK3-400
19
22
2
CK3-600
15
15
50
CK3-800
15
15
50
WARNING
Do not touch the product or approach it when power connected. Electric shock
or burns may result.
Turn off the power before starting maintenance or inspection. Failure to do so
may result in electric shock.
CAUTION
Install the product in space more than being provided by this manual. Failure to
do so may result in fire or burns.
For wiring, select wire size suitable for the applied voltage and current. Burns
may result. Tighten wires with the tightening torque specified in the instruction
manual. Failure to do so may result in fire or burns.
Do not touch the product immediately after the power is turned off. As it may still
be hot, burns may result.
Do not use the product with the arc chamber removed.
Electric shock or burns may result.
Treat the product as industrial waste when discarding.
INA-F08784813
e
-CE
使用说明书
INSTRUCTION MANUA
L
WARNING
CAUTION
30°30° 30°30°
Fig.1
Fig.2
C
接地金属或绝缘体
Ground plate or Insulator
飞弧距离
Arc space
Fig.3
OFF
ON
动作指示块
Operation indicator
Fig.4
警告
注意
螺钉头
Screw head
安装时
拆卸时
Installed Removed
Fig.5
注意
Fig.6
(CK3-105~800
请参照
9.(2))