Pronomic Minilift 120, Original Instructions Manual

Page: 65 / 303

________________________________________________________________________________
6 – Minilift 65 / 85 / 120
5 Maintenance
In order for the lift trolley to function properly it is important that maintenance is carried out in
accordance with what is described below. The stated service intervals are applicable during
normal use and charging once a day. Further use requires more frequent service intervals.
Only spare parts supplied or approved by the distributor where you bought your device may be
used.
After disassembly/assembly of the column or load carrier a load test should be performed, see
section
Assembly .
5.1 Every day
5.1.1 Charging
Only chargers supplied or approved by the distributor where you bought your device may be used.
The charger must not be exposed to water.
The lifter must be in a well-ventilated area when it is being charged
Always connect the charger to the lift trolley before connecting to the mains power.
The batteries should be recharged every night. In order to avoid complete discharge, which
damages the batteries, the batteries should also be charged when the lift trolley is not used for an
extended period of time, e.g. during weekends and holidays.
When the battery charger is connected to the lift trolley and mains power there is a yellow/orange
light on the charger, indicating on-going charging. When the batteries are fully charged the light is
green. The lift trolley can remain connected to the charger indefinitely without risk of
overcharging, preferably until next use.
For lift trolleys with a power pack equipped with a voltage indicator a flashing bar on the voltage
indicator means that the batteries need charging. If the lift trolley is left unused for 10 minutes
sleep mode is activated and the voltage indicator turns black. The lift trolley can be restarted by
pressing any button on the remote control. When the lift trolley is restarted from sleep mode
after charging it takes two minutes before the voltage indicator shows if the batteries are fully
charged.